WorkoverRigElectricCircuit修井机.ppt

Ⅰ Circuit Diagram of Chassis 底盘电路原理图 1.1 Power Unit 电源部分 Including 包括—— 1.1.1 Accumulator 蓄电池 1.1.2 Generator 硅整流发电机 1.1.3 Power Switch 电源总开关 1.1.4 Ampere Meter 电流表 1.1.1 Accumulator蓄电池 A、Supplying power for all electrical equipments before start the engine ; 当发动机未工作时，供给所有用电设备的用电； B、When engine works and generator works properly, it can save extra power as chemic energy.This is called charging. 当发动机工作，发电机正常发电时，将多余的电能以化学能的形式储存起来，即所谓充电； C、While the needs of power exceed the ability of generator, supply electrical power with the generator . 当用电超过发电机的负载能力时，与发电机共同向负载供电。 Cautions about accumulator 蓄电池 注意 ！ The ‘+’ and ‘-’ poles of accumulator must be clear before changing accumulators or using other assistant powers. ‘+’ pole of new accumulator or assistant power should be connected to ‘+’ of the old one,the same as the ‘-’ pole. If the poles are connected wrong,serious damages even fires will occurred to the circuits and generator! 更换蓄电池或使用其它辅助电源起动发动机时,必须将蓄电池“+”、“－”接线柱辨别清楚后, 再把蓄电池“+”、“－”接线柱上的连线分别接到新蓄电池或辅助电源的“+”、“－”接线柱上，绝对不允许接反；否则将引起烧毁线路和发电机的严重后果, 还可能引起火灾! 1.1.2 Generator 硅整流发电机 This generator uses silicon diode as commuting component and changes mechanical energy into electrical energy. When the generator works properly, it can provide power to electrical equipments and provide the extra power to accumulator as storages as well . 硅整流发电机是用硅二极管作整流元件的发电机，作用是将机械能转变成电能，正常工作时，一方面向用电器件供电，另一方面将多余的化学能供给蓄电池储存备用。 1.1.3 Main Power Switch 电源总开关 Cautions: While the engine is running, it is forbidden to shut off the main power switch.If it is done like this,the connections between accumulator and generator will be destroyed, the generator will lose a good smoothing element.The instant high voltage will puncture the adjustor and the semiconductors inside the generator and cause the damage of generator. 注意：当发动机运转时，绝不允许切断电源总开关，否则将损坏发电机（和调机器），因切断后，蓄电池与发电机之间的联系被切断，发电机失去了一个良好的滤波器件，但发动机仍带动发电机