混凝土搅拌机安全操作规程（六）.docVIP

混凝土搅拌机安全操作规程（六） 混凝土搅拌机安全操作规程（六）提要：作业后,应对搅拌机进行全面清洗,操作人员如需进入筒内清洗时,必须切断电源,设专人在外监护,或卸下熔断器存放好并锁好电闸箱,然后方可进入 更多精品：客服 混凝土搅拌机安全操作规程（六） 一、作业前的检查 1、固定式搅拌机的操纵台应使操作人员能看到各部工作情况,仪表指示信号准确可靠,电动搅拌机的操纵台应垫上橡胶板或干燥木板. 2、检查传动机构,工作装置,制动器等,均应紧固可靠,保证正常工作.大齿圈,皮带轮等部位,应装防护罩. 3、骨料规格应与搅拌机的性能相符,超出许可范围的不得使用. 4、向大齿圈,跑道等磨损,转动部位加注润滑油. 5、空车运转,检查搅拌筒或搅拌叶的转动方向,各工作装置的操作,制动,确认正常,方可作业. 二、作业中注意事项 1、进料时,严禁将头或手伸入料斗与机架间察看或探摸进料情况,运转中不得用手或工具等物伸入搅拌筒内扒料出料. 2、料斗升起时,严禁在其下方工作或穿行,料坑底部要设料斗的枕垫,清理料坑时必须将料斗用链条扣牢. 3、向搅拌筒内加料应在运转中进行;添加新料必须先将搅拌机内原有的砼全部卸出后才能进行.不得中途停机或在满载荷时起动搅拌机,反转出料者除外. 4、作业中如发生意外或故障不能继续运转时,应立即切断电源,将筒内砼清除干净,然后进行修理. 三、作业后注意事项 1、作业后,应对搅拌机进行全面清洗,操作人员如需进入筒内清洗时,必须切断电源,设专人在外监护,或卸下熔断器存放好并锁好电闸箱,然后方可进入. 2、作业后,应将料斗降落到料斗坑,如需升起,则应用链条扣牢. 3、移动式搅拌机长期停放或使用时间超过三个月以上时,应将轮胎卸下妥善保管,轮轴端部应做好清洁和防锈工作. 4、冬季作业后应将水泵,放水开关,量水器中的存水放尽. Measures for the routine management of moral education in Middle SchoolsMethod of conventional management of moral education in middle schoolFirst, the guiding ideology:School moral education is an organic whole of the whole education work, always adhere to the school adhere to the moral education, education for this product, and actively promote the quality education, the school building efficient curriculum system of moral education, moral education, improve the sense of attraction and appeal, enhance the moral education work for through and timeliness. Teach everyone, service education and management education, and school moral education work must be with family education and community education closely together, to form a concerted pattern, and strive to create a good atmosphere for education, and to promote the all-round development of students, to establish a scientific moral education full of vigor the For long-term mechanism.Two, the goal of moral education:To guide the students to form the correct world outlook, outlook on life, values, to cultivate students unity and mutual assistance, honest and trustworthy, law-abiding, good quali