硫酸法制取富钛料精选.docVIP

XXX学院本科毕业设计（论文） 硫酸法制取富钛料 学生姓名： 学生学号： 2 院（系）： 材料工程系 年级专业： 级材料科学与工程 指导教师： 高级工程师 助理指导教师： 高级工程师 二〇〇七年六月  摘 要 钛及其合金具有比强度高、耐腐蚀性能优、生物相容性好等优点，是航空航天装备、重大军事装备、耐腐蚀、耐压大型工业设备的重要材料；高档钛白粉是高档油漆、纸张、化纤等的着色、改性材料。随着我国综合国力的提高，它们在国内的需求量增长很快。为了满足国内日益增长的需求，要加快钛资源的开发利用，特别是生产出作为其原料的富钛料。 针对XXX铁精矿选矿—电炉熔分渣杂质Ca、Mg、Si、Al100℃、时间1小时、硫酸浓度40%、矿物粒度300目、矿酸比1：6TiO2富集渣品位可达60%左右。 关键词 熔分渣,硫酸法,排列组合实验,富钛料 ABSTRACT The titanium and its the alloy have the specific tenacity high, theanti-corrosive performance superior, the biological compatibility good and so on the merit, is the aerospace equipment, the significant military equipment, is anti-corrosive, the pressure resistance major industry equipment important material; The upscale titanium oxide powder is the upscale paint, the paper, the chemical fiber and so on the coloration, the modified material. Along with our country comprehensive national strength enhancement, they are very quick in the domestic demand quantity growth. In order to satisfy the domestic daily aggregate demand, must speed up the titanium resources the development use, especially produces takes its raw material the rich titanium material. In view of kapok ferro ore concentrate dressing - electric stove melt minute dregs impurity Ca, Mg, Si, Al and so on the organizational structure complex characteristic, unified the rich titanium material the production method, the experiment used the melt minute dregs dilute sulphuric acid leaching system to take the rich titanium material the exploration experimental study. When experiment to the different acid pickling time, the sulfuric acid density, the mineral granularity, the inorganic acid compared and so on the factor to melts a minute dregs the influence to carry on the analysis discussion. The experimental result indicated that, in the temperature 100℃, the time 1 hour, the sulfuric acid density 40%, the mineral granularity 300 items, the in