电源维修手册关键故障点与处理方案.pdfVIP

液晶电源维修手册

提示说明：在液晶电源中PFC（功率因数校正）电路和主电源驱动均由副电源供电并受

待机电路的控制以下说的无5VS（副电源）代表：24V、12V主电源也没有

32电源版本号5800-PLCD26-01（属自产）

1.故障：无5VS

检修：V601坏更换V601、故障排除V601属于压敏电阻随电压的升高而内阻减小主

要起保护作用在急需时可去掉其次如性能不良还会造成空气开关跳闸

2.故障：电源带不起负载

检修：R603（331）供电电阻开路坏后导致PFC电路不工作此时大电容两端电压只有300V

正常为380V其次ZD605(15V)ZD607(15V)击穿也会造成PFC不工作

3.故障：无5VS

检修：Q615坏NPN管可用1815代换这是副电源次级过压保护电路

4.故障：5VS输出过低

检修：C670漏电431稳压的吸收电容

5.故障：无5VS

检修：IC608坏6159更换OK这个损坏多为市电压不稳定，D61X击穿后也会屡烧

6159

6.故障：5V正常无24V12V

检修：R687限流电阻坏造成主电源无供电电压其次R673、ZD600坏后同样造成主电源无

供电导致无24V12V

7.故障：无24V12V

检修：R649（271）坏更换故障排除这是IC602的20脚电压检测外接电阻

8.故障：无5VS

检修：D617PFC功率补偿管可用RU4B代用此管击穿多烧

37电源版本号5800-P37T00-13（属自产）

1.故障：

42电源版本号5800-P40TOS-00（属自产）

LCDpowersupplyrepairmanual

Note:Intheliquidcrystalpowersupply,thePFC(powerfactorcorrection)circuitandthemainpowerdriver

chiparebothpoweredbytheauxiliarypowersupplyandcontrolledbythestandbycircuit.Thereisno5VS

(auxiliarypowersupply)representedby:24V,12V,andthemainpowersupply.

32Powersupplyversionnumber5800-PLCD26-01(self-produced)

1.Fault:None5VS

Maintenance:V601isbroken.ReceV601,insurancetroubhooting.V601

isavaristor.Theinternalresistancedecreaseswiththeincreaseofvoltage.It

mainlyysaprotectiveroleandcanberemovedwhenurgentlyneeded.

Secondly,iftheperformanceispoor,itwillcausetheairswitchtotrip.2.Fault:

Thepowersupplycannotcarrytheload.Maintenance:R603(331)powersupply

resistorisopenandbroken,causingthePFCcircuittonotwork.Atthistime,the

voltageacrossthelargecapacitorisonly