低镁钒钛磁铁矿还原行为的研究.pdfVIP

低镁钒钛磁铁矿还原行为研究 ·1 · 低镁钒钛磁铁矿还原行为研究 邢相栋 张建良 刘征建 王振阳 刘兴乐 任 山 （北京科技大学冶金与生态工程学院，北京 100083 ） 摘 要 为开发利用辽宁朝阳地区低镁钒钛磁铁矿资源，本文采用内配碳方式，研究还原温度、还原气氛及碳氧比 等因素对还原过程的影响。研究结果表明，低镁钒钛磁铁矿与攀西地区钒钛磁铁矿相比，易于还原，在研究的温度 范围内，内配碳球团均能迅速进行反应；氩气和空气两种气氛下获得的反应分数曲线具有明显区别，且二者差值随 着碳氧比的增加而降低；配碳比增加有利于反应分数的提高，但超过 1.2 之后，基本维持不变。 关键词 低镁钒钛磁铁矿 还原温度 还原气氛 碳氧比 Study on the Reduction Behavior of Low-magnesium Vanadium Titanium Magnetite Xing Xiangdong Zhang Jianliang Liu Zhengjian Wang Zhenyang Liu Xingle Ren Shan (School of Metallurgical and Ecological Engineering, University of Science and Technology Beijing, Beijing, 100083) Abstract In order to exploit the low-magnesium vanadium-titanium magnetite resources in Chaoyang area of Liaoning province, the influences on the reduction process for carbon-containing pellets of reduction temperature, reduction atmosphere and C/O (carbon oxygen mole ratio) were studied in this paper. The results showed that low-magnesium vanadium titanium magnetite was easier to be reduced compared with the one in panxi area. The pellet could be quickly reduced in the experimental temperature range. There was obvious difference for the curves of reaction fraction under different atmosphere containing air and argon, and the two difference values decreased with the C/O increase. It was beneficial to the reduction process when the C/O increased, and the reaction fraction would almost remain the same after the C/O exceeding 1.2. Key words low-magnesium vanadium titanium magnetite, reducti