并流旋转床压降数值模拟与实验.pdfVIP

摇 第35卷第8期 煤摇 摇 炭摇 摇 学摇 摇 报 Vol.35摇 No.8摇 摇 2010年 8月 JOURNAL OF CHINA COAL SOCIETY Aug.摇 2010摇 摇 摇 文章编号:0253-9993(2010)08-1369-05 并流旋转床压降数值模拟与实验 1 1 2 1 1 1 金应贵 ,李双跃 ,李摇 平 ,田摇 平 ,张亚南 ,李摇 翔 (1郾 西南科技大学 制造科学与工程学院,四川 绵阳摇 621010;2郾 绵阳市恒阳资源研究所,四川 绵阳摇 621010) 摘摇 要:为探索旋转填料床压降的影响因素,采用Fluent 软件对填料直径360 mm、高150 mm 的 CRPB3615 型并流旋转床进行气液两相数值模拟研究,与实验比较得到较好验证。 结果表明:旋转 床内压降分布是紊乱的,气体存在局部回流现象;在一定条件下,并流旋转填料床压降随液量和气 量的增大而增大,随转速的增大而减小;在气液比300(体积比)时,转速为1200 r/ min最优。 关键词:并流;旋转填料床;压降;数值模拟;两相流;转速 中图分类号:TQ05摇 摇 摇 文献标志码:A Numerical simulation and experiment on pressure drop of a co鄄current rotating packed bed 1 1 2 1 1 1 JIN Ying鄄gui ,LI Shuang鄄yue ,LI Ping ,TIAN Ping ,ZHANG Ya鄄nan ,LI Xiang (1郾College of Manufacturing Science and Engineering,Southwest University of Science and Technology,Mianyang摇 621010,China;2郾Institute of Mianyang Hengyang Resources,Mianyang摇 621010,China) Abstract:To explore the influence factors of pressure drop in a rotating packed bed,through Fluent,air鄄fluid two鄄 phase numerical simulation of a CRPB3615 co鄄currentrotatingpackedbedwasstudied.Theexperimentalresultsshow that theresultof numerical simulationissatisfactory.Theresultsindicatethatthedistributionof pressuredropisdisor鄄 der and partial reflux existsin arotatingpackedbed.Thepressure drop of a co鄄current rotatingpacked increaseswith the increasing gas or liquid flux,but decreaseswith enhanceing rotational speed under given condition.The best rota鄄 tional speed is 1200 r/ min when the gas鄄liquid flow ratio is300. Key words:co鄄current;rotating packed bed;pressure drop;numerical