水煤浆掺混湿污泥对浆体成浆特性的影响.pdfVIP

摇 第35卷摇 增刊 煤摇 摇 炭摇 摇 学摇 摇 报 Vol.35摇 Sup.摇 摇 2010年 8月 JOURNAL OF CHINA COAL SOCIETY Aug.摇 2010摇 摇 摇 文章编号:0253-9993(2010)S0-0199-06 水煤浆掺混湿污泥对浆体成浆特性的影响 王睿坤,刘建忠,胡亚轩,高夫燕,周俊虎,岑可法 (浙江大学 能源清洁利用国家重点实验室,浙江 杭州摇 310027) 摘摇 要:将城市湿污泥以不同的比例与煤粉掺混制备污泥水煤浆,研究污泥掺混量、添加剂、温度以 及剪切速率对污泥水煤浆成浆特性的影响。 结果表明:污泥掺混量增加时,污泥水煤浆的最大成浆 浓度下降;3种添加剂对普通水煤浆的分散作用相当,对于污泥水煤浆,低污泥掺混量时,石油磺酸 盐的分散作用较强,较高污泥掺混量时,亚甲基萘磺钠-苯乙烯磺酸钠-马来酸钠分散剂和甲基萘 磺酸盐甲醛缩合物的分散作用略强;浆体温度为20T50 益时,表观黏度与温度近似呈线性下降; 污泥水煤浆呈假塑性流变特征,污泥掺混量越大、浆体浓度越大,浆体的假塑性特征越明显。 关键词:水煤浆;城市污泥;成浆特性;添加剂 中图分类号:TQ536郾1;X705摇 摇 摇 文献标志码:A Influence of wet sludge on the slurrying properties of Coal鄄Water Slurries WANG Rui鄄kun,LIUJian鄄zhong,HU Ya鄄xuan,GAO Fu鄄yan,ZHOUJun鄄hu,CEN Ke鄄fa (StateKey Laboratory of Clean Energy Utilization,Zhejiang University,Hangzhou摇 310027,China) Abstract:The influences of the sludge dosages,addition agents,temperatures,and shear rates on the slurring proper鄄 ties of Coal鄄Sludge Slurries(CSSs)were investigated.The results show that the maximum solid concentration of CSSs decreases withthe sludgedosagesincreasing.Thedispersing effect of thethreedifferent addition agentson Coal鄄Water Slurries(CWSs) is matched.Petroleum sulfonate is more effective on the CSSswith lower sludge dosages,while Sodi鄄 um methylene naphthalene sulfonate Sodium styrene sulfonate Sodium maleate and Methyl naphthalene sulphonic acid鄄formaldehyde condensates aremoreeffectiveonthe CSSswithhigher sludgedosages.Approximately,theviscosity of CSSs is dropped linearly with the temperature rising at20 ~50 益.The rheological properties of CSSs are pseudo鄄 plastic,and the pseudoplasticity is more evident when the sludge dosages and solid concentration of CSSs are high. Key words:Coal鄄Water Slurries(CWSs);muni