QRD-2000(VI)清洁型焦炉砌筑规程.docVIP

QRD-2000(VI)清洁型焦炉砌筑规程Specification for Masonry Works of QRD-2000(VI) Clean Coke Oven编制：Prepared by:? ???校对：Proofread by:? ???审核：Checked by:? ???审定：Approved by:? ???December, 2007一、? ?? ???总则.? ?? ???General principles1.? ?? ???本规程只适用QRD-2000（VI）清洁型焦炉的砌筑。This specification is only applicable to masonry works of QRD-2000（VI）clean coke oven.2.? ?? ???焦炉各区域采用的耐火材料应符合设计标准的要求。Fire resisting materials used in all areas within the coke oven shall conform to requirements of design standard.3.? ?? ???焦炉施工过程中发生材料代用、技术质量问题处理、变更设计等事宜时，要预先取得设计部门同意，并签发设计通知单后方可施工。Material substitution, technical and quality problems handling, design variation and other affairs during construction of coke oven shall be authorized by design unit and the construction shall not be performed until design change notice is signed and delivered. 4.? ?? ???整座焦炉耐火材料应采用同一个耐火材料厂生产，并质量指标相同的耐火材料。Fire resisting materials used for one coke oven shall be from one manufacturer and of same quality indexes.5.? ?? ???砌筑硅砖焦炉应在工作棚内进行，工作棚净空尺寸除应满足炉体施工外还应满足作业平台、集气管、除尘风管和护炉[wiki]设备[/wiki]的安装工作。Masonry works of silica brick coke oven shall be within work shed and the clearance of the work shed shall not only meet requirements of construction of oven shell but also installation of work platform, header, dedusting wind pipe and protective devices.6.? ?? ???焦炉砌体在烘炉前应防潮防冻，并保持5以上[wiki]环境[/wiki]。Masonry works shall be protected from moisture and frost and the ambient temperature shall be above 5.7.? ?? ???具备下列条件时，允许开始砌筑焦炉：Masonry works shall not be started unless the following conditions are ready:(1)? ?? ???焦炉基础、抵抗墙等土建构筑物已施工完毕并验收合格。Construction of coke oven structures such as foundation and resistance wall have been finished, inspected and accepted.(2)? ?? ???筑炉大棚及相应的取暖、照明、防火装置和设备均已安装完毕，运送耐火砖及灰浆到现场。Construction shed and related heating, lighting, fire protection device and equipment have been installed and firebricks and mortar have been transported into the construction site.(3)? ?? ???检查砌砖质量及标定中心线