中藥粉气悬浮臭氧逆流接触灭菌方法的研究040511(定稿投中国药学杂志).docVIP

PAGE PAGE 7 中药粉气悬浮臭氧逆流接触灭菌方法的研究 宋丽丽1 范丙义 1 谷传动2 卢鹏伟1 何 颖1 张启明1 张 瑜1 杨 珂1 朱新科1 （1 河南大学，开封475001；2 中仁工贸有限公司，郑州450047） 摘 要：目的 臭氧技术应用于中药粉的灭菌。方法 采用气悬浮臭氧逆流接触灭菌方法，对砂仁、豆蔻等原生药粉及六味地黄丸等制剂的混合药粉进行灭菌处理，进行灭菌效果观察及工艺条件筛选；选择山茱萸等六味药材的原生药粉，进行流通蒸汽灭菌、干热灭菌、60Co辐射灭菌和臭氧灭菌的比较研究，在统计比较样品灭菌效率的同时，分别对其灭菌前后的X射线衍射光谱（XRD）和红外光谱（IR）进行进行聚类分析，以探讨化学成分的变异，并对样品中目标成分丹皮酚、熊果酸的含量损失率进行对比分析。 结果 臭氧灭菌法对样品的灭菌率平均为95.24%，比干热灭菌法高6.81%，稍低于60Co辐照灭菌法和流通蒸汽灭菌法；对样品化学成分的影响较小，其优越性高于流通蒸汽灭菌法和干热灭菌法。 结论 臭氧技术用于中药粉的灭菌效果稳定，对成分损坏较小，可在常温常压条件下同上下游工序联动操作，是中药大生产中对入药生药原粉在线灭菌的优良方法。 关键词：臭氧灭菌；中药粉；灭菌率；成分 Study on Application of the Air-floating Countercurrent-contacted Sterilization of TCM Powder by Ozone Technology Song Li-li1, Fan Bing-yi1, Gu Chuan-dong2, Lu Peng-wei1, He Ying1, Zhang Qi-ming1, Zhang Yu1, Yang Ke1, Zhu Xin-Ke1 (1 Henan University, Henan Abstract Objective: To apply ozone technology in the sterilization of the TCM (Traditional Chinese Medicine) powder. Methods: By means of air-floating ozone countercurrent-contacted sterilization, the powders of crude Sharen and Doukou etc. and the mixture powder of Liuweidihuang pills and so on were sterilized by ozone，the sterilization effects of which were observed, and the processing conditions of which was selected. Six raw powders in Liuweidihuang pills were sterilized respectively by dry-heating, circulating steam, 60Co and ozone. The chemical components were analyzed before and after sterilization by means of XRD and IR, and the results were clustered as well, to probe into their variations of the chemical components. The decreasing rate of Paeonol and Ursolic acid were compared. At the same time, the sterilization efficiency was conducted statistics and comparison. Results: The average sterilization rate of the samples by ozone sterilization method was 95.24%, 6.81% higher than that sterilized by dry-heating，and slightly lower than that sterilized by 60Co radioaction and circulating steam. Ozone sterilization method had no obvious influence on the chemical components