膜结构施工监理细则膜结构施工监理细则.docxVIP

编号：细则018SN: XZ 018迪士尼明日世界项目工程Disneyland Tomorrowland ProjectETFE膜结构施工监理细则ETFE Membrane Structure Construction Supervision Scheme编制人：总监理工程师：批准时间：上海建科工程咨询有限公司Shanghai Jianke Engineering Consulting Company Limited迪士尼明日世界项目监理项目部Disneyland Tomorrow Land Supervision Project Department目录工程概况Project Overview上海迪士尼乐园项目GC-5明日世界迪士尼片区位于迪士尼西南角，紧靠西门；明日世界308单体天幕钢结构正在施工，天幕膜结构工程由72块ETFE气枕组成，最大气枕约为70米长，3米宽，面积约200平方米，最小气枕长为8米，面积约为20平方米。ETFE气枕是迪士尼定制的双层蓝色带印花图案。外围由508块连续的不规则铝板组成收边，铝板表面是业主选择的变色龙油漆喷涂。Shanghai Disneyland GC-5 Tomorrowland is located in the southwestern side and close to west entrance. TL 308 Canopy steel structure is under construction. The canopy membrane consists of 72 pieces of ETFE air cushion of which the biggest is about 70m long and 3m wide with an area of about 200 square meters and the smallest is about 8m long with an area of about 20 square meters. ETFE air cushion has double-layer blue printed pattern specially designed for Disney. 508 pieces of continuous irregular aluminum panel form the lining. On the surface of aluminum panel is Chameleon paint applied. 编制依据References迪士尼明日世界技术规格书，章节号13.31.00；Section 13.31.00 of Disney Common SPEC设计蓝图及设计师审批通过的深化图纸；Blue printed drawing and shop drawing approved by designers 《建筑结构荷载规范》GB5009-2012Building Structure Load Code 《膜结构技术规程》CECS-158-2004Technical Regulations for Membrane Structure 其他与本工程相关的国家规范、法规及标准；Other related national code, law and standard 施工准备工作Construction Preparations审核膜结构安装、制作、加工、安装企业资质及质量管理体系，核查企业管理及人员资质。Review company qualification and quality assurance system of the installation, fabrication and processing contractors; check the qualification of its managers and technicians. 审核施工单位提交的施工组织设计方案，审核制作安装工艺、焊接工艺、涂装工艺等工艺评定的覆盖范围是否适合本工程的要求。Review construction organization plan, installation, welding and painting procedures submitted by the contractor. 图纸审核，查验施工检测方法及各项检测措施落实情况。（监理总包钢结构制作安装，膜结构制作安装等各单位测量工艺应统一标准）Jointly review drawings and confirm construction testing method and testing implementation status (Jianl