雨污水管道施工方案..docxVIP

荆山大道南段（凤袁路～南三环）市政道路及配套项目施工 （二标段）雨、污水管道施工方案编 制 人：审 批 人：编制时间：目 录一、设计概况·························································1一、编制依据·························································1三、施工方法·························································21、施工部署·······················································22、施工流程······················································23、施工工艺·······················································21）沟槽开挖···················································42）沟槽开挖允许偏差和检测方法·································43）管材、接口与管基············································64）沟槽排水··················································65）沟槽基础···················································66）管道铺设····················································77）管道连接····················································78）砖砌检查井与钢筋混凝土检查井施工···························109）管道胸腔回填···············································13五、注意事项························································16六、质量标准························································16七、排水管道施工常见质量通病与防治··································17八、安全文明措施····················································20一、设计概况本次设计荆山大道红线宽40m，布置双排雨水管及单排污水管道，分别描述如下：1、雨水管道分别位于设计道路西侧距道路中线11.5m 处以及设计道路东侧距道路中线8m 处。沿线布置d500~d2000mm 雨水管道收集雨水，分两段经下游规划雨水管涵，最终排入凤凰河。2、污水管道位于设计道路东侧距道路中线11.5m 处。沿线布置d800mm~d1000mm 污水管道，收集污水并承接上游转输污水，在崇仁路道口附近以及桩号JS9+180附近汇集后向西穿铁路，排入铁路西侧新埠河（车桥河）截污干管，最终接入团林污水处理厂。3、管线标准横断面图如下：二、编制依据1、《排水工程》施工图2、本工程地勘报告3、《给水排水管道工程施工及验收规范》GB 50268-20084、《市政排水管道工程及附属设施》国家建筑标准设计图集 06MS2015、《市政公用工程细部构造做法》湖北省工程建设标准设计推荐 13EZ0016、《给水排水构筑物工程施工及验收规范》 GB 50141-2008三、施工方法1、施工部署全线根据工作面的提供进度分段开挖，先开挖东侧雨、污同槽管沟，再开挖西侧雨水管沟，余土外弃，分段施工，分段验收。全线拟配置主要资源如下：主要施工机械配置表机械设备名称一工区（JS3+050～JS5+130）二工区（JS5+130～JS7+940）三工区（JS7+940～JS9+801）336D卡特挖机58615t自卸车253020山推TY180型推土机2徐工PY165G型平地机215t汽车吊11118t压路机2蛙式打夯机35210m3洒水车22t农用车232主要劳动力配置表工种人数（人）备注管道安装工30管道转运、安装泥工35检查井砌筑木工15检查井支模钢筋工10检查井钢筋制作、绑扎砼工5检查井砼浇筑、养护杂工6场地排水、临边防护搭设2、施工流程测量放线→沟槽开挖→管基处理→管道基础施工→管道安装→管接口施工→检查井施工→闭水