改性湿强用pae树脂的性能研究_毕业论文.doc

毕业（设计）论文 题 目 改性湿强用PAE树脂的性能研究 武汉工程大学本科毕业论文 改性湿强用PAE树脂的性能研究 the properties of modified PAE resin on wet strength 学生姓名 指导教师 武汉工程大学本科毕业论文  PAGE \* MERGEFORMAT I 武汉工程大学本科毕业论文  PAGE \* MERGEFORMAT I 摘 要 纸张是人们生活中的必需品，为了节能环保，目前造纸工业中抄造纸张的原材料已经从原生木浆转化为废纸浆与木浆配抄或者全为废纸浆，但造出的纸张性能会大大降低。聚酰胺环氧氯丙烷(PAE)做湿强剂有很强的适用性，但其稳定性差、有机氯含量高、固含量低、价格昂贵的缺点制约着PAE树脂的广泛使用。 本文采用羧基改性剂丙烯酸对PAE树脂进行改性，通过酯化反??将丙烯接枝到PAE树脂上。主要探讨了改性剂对固含量的影响，PAE固含量和丙烯酸用量对接枝效率效率的影响，并对改性PAE树脂进行了红外表征。 实验结果表明，PAE 树脂与丙烯酸单体的最佳接枝共聚的条件为：反应时间 80min，反应温度为70℃，选用对甲苯磺酸为催化剂。傅里叶红外光谱图出现不饱和丙烯酸酯羰基伸缩振动峰（νc=o）和C（C=O）-O 伸缩振动峰（νc-o-c），表明PAE树脂与丙烯酸单体发生了接枝共聚，且双键没有遭到破坏。在饱和PAE树脂固含量较低时丙烯酸的接枝效率较高，在一定的范围内丙烯酸的接枝效率会随醇酸比例的增加而提高。改性PAE树脂的固含量较饱和PAE树脂的固含量有一定程度的提高。 关键词：PAE树脂；丙烯酸；改性；接枝共聚；固含量  PAGE \* MERGEFORMAT III Abstract The paper is?the necessities of life,?in order to?energy saving and environmental protection, the raw material of life paper in the paper industry has been gradually transformed from native wood pulp to waste paper pulp or the mixed use of virgin wood pulp and waste paper pulp.?but the?properties of paper??will be greatly reduced.?Polyamide epichlorohydrin?(PAE)?as?a wet strength agent?has very strong applicability,?but its?poor stability,?organic?chlorine?content is high,?low solid content and high price?disadvantage?restricts the wide?use?of PAE resin. The?carboxyl group?modification of PAE?resin was?modified with acrylic acid?by etherification?agent,?acrylic?grafted onto?PAE resin.?Mainly discusses the influence of modifier on?solid content,?effect of PAE?solid content and?the amount of acrylic acid?on the grafting?efficiency,?and the modification?of PAE resin?was characterized by FTIR. The experimental results show that,?the optimal?graft copolymerization conditions?of PAE resin?with acrylic?monomer:?reaction time 80min,?reaction temperature at70℃,?using p-toluene sulfonic acid as catalyst.?FTIR?of unsaturated?ester?carbonyl stretching vibration pea