建筑混凝土工程施工工艺（三）.docVIP

建筑混凝土工程施工工艺（三） 建筑混凝土工程施工工艺（三）提要：柱子砼浇筑：先从柱子一端开始循环浇筑，每次浇筑高度小于等于500mm 建筑混凝土工程施工工艺（三） 1.本工程采用现场拌砼。 2.为保证砼质量，首先要选好砂、石料场规模，与其合作的水泥厂及外加剂厂的产品信誉，装备的运输车数量，供货到现场的距离和时间，价格及服务等因素进行评审，作出最佳选择，并报公司备案。 3.在签订合同的同时，要向供方提出供货的技术要求，明确砼强度，坍落度、粗集料粒径、水泥品种及标号，防水砼抗渗等级、外加剂品种、掺合料品种及规格等技术指标。 4.供货方提供的资质证书、试验报告和供货小票是其质量保证资料。必须齐全有效，要归档保存。 5.砼强度试验分别按GB107-87标准取样试验。 6.不准向砼拌合物中任意加水以增大坍落度的错误做法。 7.底板砼浇筑：铺设砼管道采用边浇筑边拆管的方法。由西向东，浇筑砼采用的自流斜面分层一次到顶法，每作业面分前、中、后三排振捣砼，边浇筑边成型及抹平底板表面，标高、厚度采用水准仪定点测平，用小白线严格控制板面标高和表面平整，顶、底板砼振捣见下图。 8.柱子砼浇筑：先从柱子一端开始循环浇筑，每次浇筑高度小于等于500mm，前后两次浇筑时间为前次砼停止流动，但在终凝前进行下次浇筑、顶部拉线抹平、无松散砼、并且将粘附在钢筋及模板上的水泥浆及时清理干净。 9.浇筑顶板砼时从一端开始，边铺砼边振捣、边抹平。浇砼采用”赶浆法”连续向前进行。 （1）竖缝：±以下外墙不留竖缝，内墙及±以上墙体留在受剪较小处，板、梁留置在中间1/3跨内。竖缝内设置一层钢板网、木板支堵，木板宽度为墙厚度减去两侧保护层及钢筋直径，并加横支撑箍见下图。 （2）水平缝：±以下，地下室外墙留在底板上皮300mm，内设钢板止水带。 10.梁、柱及墙体节点处钢筋稠密部位采用振动棒重点振捣，并配合Ф30振捣棒振捣，防止出现漏振。 Measures for the routine management of moral education in Middle SchoolsMethod of conventional management of moral education in middle schoolFirst, the guiding ideology:School moral education is an organic whole of the whole education work, always adhere to the school adhere to the moral education, education for this product, and actively promote the quality education, the school building efficient curriculum system of moral education, moral education, improve the sense of attraction and appeal, enhance the moral education work for through and timeliness. Teach everyone, service education and management education, and school moral education work must be with family education and community education closely together, to form a concerted pattern, and strive to create a good atmosphere for education, and to promote the all-round development of students, to establish a scientific moral education full of vigor the For long-term mechanism.Two, the goal of moral education:To guide the students to form the correct world outlook, outlook on life, values, to cultivate students unity and mutual assistance, honest and trustworthy,