搅拌机使用时安全技术交底（三）.docVIP

搅拌机使用时安全技术交底（三） 搅拌机使用时安全技术交底（三）提要：检查传动离合器和制动器是否灵活可靠，钢丝绳有无损坏，轨道滑轮是否良好、周围有无障碍及各部位的润滑情况等 建设集团有限公司 搅拌机使用时安全技术交底 1.搅拌机应设置在平坦的位置，用方木垫起前后轮轴，使轮胎搁高架空，以免在开动时发生走动。操作时必须遵守搅拌机安全操作规程。 2.电源接通后，必须仔细检查，经空车试运转认为合格，方可使用。试运转时应校验拌筒转速是否合适，一般情况下，空车速度比重车（装料后）稍快2～3转，如相差较多，应调整动轮与转动轮的比例。 3.拌筒的旋转方向应符合箭头指示方向，如不符时，应更正电机接线。 4.检查传动离合器和制动器是否灵活可靠，钢丝绳有无损坏，轨道滑轮是否良好、周围有无障碍及各部位的润滑情况等。 5.开机后，经常注意搅拌机各部件的运转是否正常。停机时，经常检查搅拌机叶片是否打弯，螺丝是否打落或松动。 6.当混凝土搅拌完毕或预计停歇1小时以上，除将余料出净外，应用石子和清水倒入搅拌桶内，开机转动，把粘在料筒上的砂浆冲洗干净后全部卸出。料筒内不得有积水，以免料筒和叶片生锈。同时还应清理搅拌筒外积灰，使机械保持清洁完好。 7.下班后及停机不用时，将保险丝取下，以策安全。 8.补充交底内容： 工程名称：交底人：单位：班组： 年 月 日 Measures for the routine management of moral education in Middle SchoolsMethod of conventional management of moral education in middle schoolFirst, the guiding ideology:School moral education is an organic whole of the whole education work, always adhere to the school adhere to the moral education, education for this product, and actively promote the quality education, the school building efficient curriculum system of moral education, moral education, improve the sense of attraction and appeal, enhance the moral education work for through and timeliness. Teach everyone, service education and management education, and school moral education work must be with family education and community education closely together, to form a concerted pattern, and strive to create a good atmosphere for education, and to promote the all-round development of students, to establish a scientific moral education full of vigor the For long-term mechanism.Two, the goal of moral education:To guide the students to form the correct world outlook, outlook on life, values, to cultivate students unity and mutual assistance, honest and trustworthy, law-abiding, good quality, hard work, set a good XX students ideological quality, psychological quality and image quality. The formation of excellent moral education curriculum system and management system, the construction of school. The s