大掺量粉煤灰泵送混凝土早期抗压强度的试验研究.pdfVIP

学兔兔 2014年第 9期(总第 299期 ) 混 凝 土 理 论 研 究 Number 9 in 2014(Total No．299) Concrete THE0RETlCAL RESEARCH 大掺量粉煤灰泵送混凝土早期抗压强度的试验研究 刘思海，侍克斌。吴福飞 (新疆农业大学 水利与土木工程学院，新疆 乌鲁木齐 830052) 摘 要：通过理论分析和试验，研究了大掺量粉煤灰对混凝土早期抗压强度及成本的影响。试验所选用的胶凝材料总量为375kg． 以0-55％的粉煤灰替代水泥，减水剂的掺量固定为1．O％，引气剂的掺量固定为1．2‰。通过坍落度及不同龄期抗压强度等对比分析 粉煤灰掺量对混凝土和易性及早期强度的影响。结果表明，混凝土早期抗压强度及成本随着粉煤灰掺量的增大而逐渐减小，运用粉 煤灰等质量代替水泥(P·O 42．5级水泥)可配制出28 d抗压强度为20 MPa以上，成本大大降低的大掺量粉煤灰混凝土。研究的结论 为新疆地区粉煤灰的应用提供了有效途径，有助于制备高性能混凝土。 关键词：粉煤灰；泵送；混凝土；和易性；早期强度 中图分类号：TU528．O1 文献标志码：A 文章编号： 1002—3550(2014)09—0049—04 Experimental study of high volume fly ash pumping concrete compressive strength early U【，Sihai，SHIKebin，WUFufei (College ofCivil andHydraulicEngineering，Xi~iangAgriculturalUniversity，Urumqi 830052，China) Abstract： Through theoretical analysis and test，studied the effect ofhigh volume fly ash on concrete compressive strength and cost．To— tal cementitious materials test for the selected 375 kg，with 0-55％fly ash instead of cement，the amount of superplasticizer was fixed at 1％．dosage ofair entraining agent was fixed at 1．2％0o．Through the slum p and compressive strength ofcomparative analysis ofthe influence of fly ash on concrete workability and early strength．The results showed that，the concrete compressive strength and cost decreased gradu— ally with the increase in the amount of fly ash，fly ash and other quality instead of using cement(42．5 ordinary portland cement)can be made by 28 d compressive strength was more than 20 MPa，a large amount offly ash can reduce the cost ofconcrete．Provided an effective wayfor research conclusionwasthe applicationofflyashinXinjiang，contributedt