CTD5143PP1.230HourConstructionSafetyCraneSafety程序.ppt

Crane Safety-Construction起重机安全-建筑 Crawler Crane Components 履带式起重机部件图 Follow Manufacturers Instructions遵循制造厂商使用指导 Consensus Standards常用标准 Consensus Standards通用标准 Inspection, Testing Maintenance检查，测试和维护 Inspection, Testing Maintenance检查，测试和维护 Shift Inspections:当班检查： Inspection, Testing Maintenance检查，检测以及维护 Monthly Inspections月检 Inspecting Crane Components检查起重机部件 Inspection, Testing Maintenance检查，测试以及维护 Inspection, Testing Maintenance检查，测试和维护 Inspection, Testing Maintenance检查，测试和维护 New Crane Inspections新起重机的检查： Annual Inspections年检 Inspection, Testing Maintenance检查，测试和维护 Cranes that haven’t been used: 已经长时间未使用的起重机： Inspection, Testing Maintenance检查，测试和维护 Cranes after repair维修后的起重机： Crane Inspection起重机检查 Inspection, Testing Maintenance检查，测试和维护 Load testing a used crane: 对用旧了的起重机进行负荷试验： Inspection, Testing Maintenance检查，测试和维护 Preoperational Tests - General: 空运转测试-概要 Inspection, Testing Maintenance检查，测试和维护 Preoperational Tests - Rope: 空运转测试-绳索： BASICS OF CRANE SAFETY起重机安全的基础 Big Blue Crane Collapse蓝色巨人起重机事故 “Big Blue” Statistics (1999)“蓝色巨人”统计表（1999） Location: Milwaukee, Wisconsin 地点：威斯康星州，密尔沃基 Project: Miller Park stadium 工程：米勒花园大型露天运动场 Time: 5:15 PM 时间：下午5:15 The Pick: Stadium roof section (4R-Block 3) 挖掘：运动场顶部（4R-滑轮3） Suspended Weight: 450 tons 悬吊重量：450吨 Crane: Special Design only used once before 起重机：特殊设计的起重机，在此之前只用过一次 Counter Weight: 1150 tons 实际重量：1150吨 Boom Length: 567 ft. (172.8 m) 起重臂长度：567英尺（172.87米） Wind Gusts: 26 mph (41.8 kilometers/hr.) 阵风速：26英里每小时（41.8千米每小时） Recommendations in engineering calcs-15 mph (21 kilometers/hr.) MAXIMUM!!! 建议在工程施工中 最大为15英里每小时（21千米每小时）！！ Were Safety Issues ?是安全问题吗？ Anemometers were installed both on the tip of the crane and the roof section 在起重机尖端和屋顶部分都安装有风速计 Wind speeds averaged 21-22 mph with gusts to 27 mph (15 mph was the recommended speed)