抗折剂在路面水泥混凝土工程中应用研究.pdfVIP

学兔兔 2010年 第 2期 f总 第 244期 ) 混 凝 土 原材料及辅助物料 Number 2 in 2O10(Total No．244) Concrete MATERIAL AND ADMINlCLE doi：10．3969~．issn．1002—3550．2010，02 027 抗折剂在路面水泥混凝土工程中的应用研究 黄利频。郑建岚 (福州大学 土木 程学院，福建 福州 350108) 摘 要：分析了水泥混凝土路面特性，提出r掺加抗折制对路面混凝土进行技术改性的方法。采用3种抗折剂，配制出水泥用量可低至 325 kg／m3的满足高等级公路路面强度要求的混凝土。各项力学性能试验结果表明：抗折剂能显著提高混凝土28 d抗弯拉强度，且使混凝 土具有较高的拉压比，韧性得到改善。对早期抗弯拉强度提高作用明显的抗折剂，能使混凝土7 d就达到强度设计要求。抗折剂作为一种 新型复合外加剂，只有明确其主导化学成分，了解其作用机理，才能更好地加以推广应用，发挥效益。 ． 关键词：路面混凝土；混凝土抗折剂；配合比；抗弯拉强度 中图分类号： TU528 042 文献标志码： A 文章编号： 1 002—3550(2009)02—0094—03 Application of anti-breaker admi~ures in pavement cement HUANGLi-pin，ZHENGJian-lan (College ofCivil Engineering，FuzhouUniversity，Fuzhou 350108，China) Abstract： The mechanical behavior of cement concrete pavement were analyzed，and the method，using the anti—breakers to promote the prop- erties ofpavement cement．was putted forward．The mechanical properties ofthe concrete with three kinds ofanti—breakers were studied in the ex— perimental investigation．It is indicated that the anti—breakers can raise not only the 28d flexuml strength but also 28d flexural compressive strength ratio significantly，SO the tenacity ofconcrete can be enhanced．When the amount ofcement was reduced to 325 kg／m’，the concrete can also meet the strength requirements for high-grade highway．As the new compound admixtures．it’S very important that the anti—breakers’leading chemical compositions and their mechanism ofaction should be made clear before good applications． Key words： pavement cement；concrete anti—breaker；mix