拉法基水泥集团--设备调试说明30.docVIP

Test Commissioning Electrical: Energizing MCC No of pages / Equipment Item: Issue Date: 11th Oct., 2008 Rev: R00 Item N° Sheet No. Checking before Energizing 送前前检查 Erection 安装 MCC cabinets have been erected ; incoming cables have been test and connected the incoming of MCC MCC柜已安装完成，MCC进线电缆测试并已连接至MCC进线柜 Earthing system for子MCC is installed MCC接地系统已完成 Lighting in switch-room is normal operation 电力室内照明已完成 Fire detection system in switch-room is normal operation 火灾报警系统安装已完成 Each emergency Shut-Downs for switch-room has been installed 电力室紧停开关已安装完成 Civil works for switch-room has been finished 电力室土建工程式已完成 □ □ □ □ □ □ Security Check 安全检查 No debris in electrical room, 电力室内无杂物 All feeder of MCC have been take out and locked MCC所有回路已拉出，并已上锁， Fire detection system are normal operation; 火灾报警系统已能正常工作; Lighting is normal operation 照明正常 Earthing for MCC has been finished MCC接地已完成 Emergency Shut-Down has been erected 紧停开关已安装完成 Necessary warning plates have been erection in the witch-room 必须的警告牌已准备好 The doors for electrical room can be locked 电力室门能够上锁 □ □ □ □ □ □ Electrical check 电气检查 Clean the electrical room, no debris in electrical room, 电力室内清理干净，室内无异物； Clean the MCC cabinet, 清理MCC柜 Check the cables erection conditions, such as fixed, no mechanical damage, good arrange and seal. 检查电缆接线是否已完成，电缆布置是否合理，电缆排列整齐，固定是否可靠，接线室内是否密封良好 I/O lists between PLC to MCC incoming have been checked. MCC 进线柜至PLC的I/O点已检查； Setting value for protection of MCC incoming breaker has been done according to drawings requirement. MCC进线柜保护设置已根据图纸设定完成 Temporary auxiliary power from ACC and UPS have been normal operation, 临时辅助电源，UPS电源已正常工作 The door of electrical room can be locked 电力室门能够上锁 □ □ □ □ □ □ □ Electrical test 电气测试 Insulation for MCC bar bus and breaker meet the requirement MCC母线与断路器回路压侧绝缘测试满足要求 Insulation for LV cables meet requirement, the cables connect is correct, 低压动力电缆绝缘满足要求，电缆接线正确 Ensure the Operation of breaker on MCC incoming in normal operation, the status is