特殊气体阀门培.ppt

Used for high purity gases, rare gases, toxic gases 用于高纯度气体、稀有气体、毒气 Two piece stem connected through the diaphragm 上下阀杆通过膜片联结 no spring, lower stem physically pulled away from seat 没有弹簧、下阀杆被拉离阀座 ? turn to achieve full flow 转3/4圈全开 Leak check port on side of valve to check for diaphragm leaks 阀门侧有检漏口，用来检查膜片是否泄漏 Better for high-purity services, much lower internal volume and no spring 比较适合高纯度气体供应 Double Closure technique needed 需要“双关闭技术” Can open from vibration – wire-tied shut on toxics, pyrophorics 振动可能打开阀门 – 毒性、自燃性气体阀门须用线栓死。 Confirm valve is closed before you remove outlet seal 取下出口密封前，确定阀门是关紧的 RFO’s often added for hazardous gases 对毒性气体通常加限流装置 Tied-Diaphragm Valve 膜片与阀芯联结的阀门 Pneumatic Tied Diaphragm Valve 气动膜阀 Actuation Pressure Inlet 压缩空气入口 Shipping Lock 阀锁 Lock Position Indicator 锁紧位置指示 Ceodeux Pneumatic Valves Ceodeux气动阀门 CEODEUX HI-FLOW PNEUMATIC Used for high purity gases, pyrophoric gases and toxic gases – electronics industry 用于高纯度气，自燃气体和毒气 – 电子工业 Remotely operated with 60 -100 psig of nitrogen 远程控制60-100psig氮气 Fail-Closed Design 故障自动关闭设计 Lose nitrogen pressure - valve will close 没有氮气压力，阀门会关闭 Red pin in with shipping lock turned hard all the way clockwise – valve closed and locked, ready for shipment 红色针形标志在锁紧位置，顺时针很难扭动 – 这时阀门关闭并锁紧，准备运输 Red pin out – valve ready to be used 红色针形标志出来 – 阀门准备使用了 Manual operator available for ER use, etc. 紧急应变时也可手动。 Pneumatic Tied Diaphragm Valve 气动膜阀 Neriki Pneumatic Diaphragm-on-Seat Valve - ClF3Neriki 气动膜阀（隔膜在阀座上） – ClF3 Actuator gas port制动器气口 Shipping Lock 阀锁 Manual Override port 手动超驰口(采用手控方式来