发泡EVA垫片鉴定图谱.doc

普什公司研发中心高分子材料研发室 PAGE PAGE 2 EVA、发泡EVA垫片鉴定图谱 普什公司研发中心高分子材料研发室 2006.11.26 一、FDA的规定：EVA类塑料禁止用于白酒包装 对于与酒直接接触的瓶盖零部件材料的适用性判断，主要参考美国的FDA标准。在FDA的条文中与EVA相关的是21CFR177.1350，其中规定EVA只可以作为与酒精含量8％以下的饮料相接触的部件使用是才是安全的。 TITLE 21--FOOD AND DRUGS CHAPTER I--FOOD AND DRUG ADMINISTRATION, DEPARTMENT OF HEALTH AND HUMAN SERVICES (CONTINUED) PART 177_INDIRECT FOOD ADDITIVES: POLYMERS--Table of Contents Subpart B_Substances for Use as Basic Components of Single and Repeated Use Food Contact Surfaces Sec. 177.1350 Ethylene-vinyl acetate copolymers. The copolymers shall be used in blends with other polymers at levels not to exceed 17 percent by weight of total polymer, subject to the limitation that when contacting food of types III, IV-A, V, VI-C, VII-A, and IX, identified in Sec. 176.170(c) of this chapter, Table 1, the polymers shall be used only under conditions of use C, D, E, F, and G, described in Sec. 176.170(c) of this chapter, Table 2.（EVA类共聚物与其它聚合物混合使用量不超过聚合物总重量17％，除限制与21CFR176.170(c)表1中所列的第III, IV-A, V, VI-C, VII-A,和IX类食品接触外，与其它类食品接触时也只能在21CFR176.170（c）中所列的C、D、E、F和G条件下使用。） Table 1--Types of Raw and Processed Foods表1食品分类 VI. Beverages:饮料 A. Containing up to 8 percent of alcohol.含8％以下酒精的饮料 B. Nonalcoholic.不含酒精的饮料 C. Containing more than 8 percent alcohol.含8％以上的酒精饮料 二、发泡EVA垫片材料的TGA鉴定图谱 三、不同VA含量的EVA鉴定TGA图谱 EVA 3610F TGA图谱 EVA V4110F EVA V5110J