生活-消防双恒压供水控制系统设计.docVIP

摘要 本论文根据中国城市小区的供水要求，设计了一套基于PLC的变频调速恒压供水系统, 并利用。变频恒压供水系统由可编程控制器、变频器、水泵机组、压力传感器等构成。 本系统包含三台水泵电机，它们组成变频循环运行方式。采用变频器实现对三相水泵电机的软启动和变频调速，运行切换采用“先启先停”的原则。压力传感器检测当前水压信号，送入PLC与设定值比较后进行PID运算，从而控制变频器的输出电压和频率，进而改变水泵电机的转速来改变供水量，最终保持管网压力稳定在设定值附近。  ABSTRACT According to the requirement of Chinas urban water supply, this paper designs a set of water supply system of frequecey control of constant voltage based on PLC, and have used MATLAB software to carry out the parameter setting.The system is made up of PLC, transducer,units of pumps,pressure sensor and control machine and so on. This system is formed by three pump generators,and they form the circulating run mode of frequency conversion. With general frequency converter realize for three phase pump generator soft start with frequency control,operation switch adopts the principle of”start first stop first”. The detection signal of pressure sensor of hydraulic pressure,via PLC with set value by carry out PID comparison operation,so,control frequency and the export voltage of frequency converter,and then the rotational speed that changes pump generator come to change water supply quantity,eventually,it is nearby to maintain pipe net pressure to stabilize when set value. Keywords: variable frequency speed-regulating, constant-pressure water supply, PLC  目录 1 绪论...............................................................1 1.1 课题的提出......................................................1 1.2 变频恒压供水系统的国内外研究现状 ...............................2 1.2.1 变频调速技术的国内外发展与现状...............................2 1.2.2 变频恒压供水系统的国内外研究与现状...........................2 2 系统的理论分析及控制方案确定.......................................4 2.1 变频恒压供水系统的理论分析......................................4 2.1.1 电动机的调速原理.............................................4 2.1.2 变频恒压供水系统的节能原理...................................4 2.1.3 管网设定水压的水力计算.......................................7 2.2变频恒压供水系统控制方案的确定...................................8 2.2.1控制方案的比较和确定...............................