掺粉煤灰和石灰粉影响再生混凝土自收缩变形的试验研究.pdfVIP

文章编号：1007-046X(2013)01-0037-03 生态建材 掺粉煤灰和石灰粉影响再生混凝土自收缩变形的试验研究 Experimental Study of Effects of Fly Ash and Lime Powder on Autogenous Shrinkage Deformation of Recycled Concrete 花丽君 吴相豪 袁 潘 （上海海事大学 海洋环境与工程学院，上海 201306 ） 摘 要： 采用非接触式混凝土收缩仪测定再生混凝土自收缩变形值，研究单掺粉煤灰与双掺粉煤灰和石灰粉对再生 混凝土自收缩变形的影响。试验结果表明：粉煤灰等量取代水泥时，随着粉煤灰取代率的增加，再生混凝 土试件的自收缩率是先减小后增大，取代率为 20% 的再生混凝土自收缩率最小；粉煤灰和石灰粉等量取 代 40% 水泥时，随着石灰粉掺量比重的增加，粉煤灰再生混凝土试件自收缩率也是呈先减小后增大趋势， 石灰粉掺量为 4% 的粉煤灰再生混凝土自收缩率最小，但减小幅度不大。 关键词 ： 粉煤灰；石灰粉；再生混凝土；自收缩变形 中图分类号：TU528.2 文献标 志码：A Abstract ：Autogenous shrinkage deformation of recycled concrete was tested by non-contact concrete shrinkage deformation analyzer. The effects of single or double mixed fly ash and lime powder on autogenous shrinkage of recycled concrete were researched. The results showed that: when substituting fly ash for isometric cement, shrinkage of recycled concrete increased firstly, then decreased with the volume of fly ash raising, shrinkage of recycled concrete containing 20% fly ash is minimum; substituting fly ash and lime dust for 40% cement, shrinkage of recycled concrete also decreased firstly, then increased with the increase of the proportion of lime dust. The best proportion replacing fly ash with lime powder was 4% when shrinkage of recycled concrete was minimum, but the decline was not obvious. Key words fly ash; lime powder; recycled concrete; autogenous shrinkage deformation 0 前 言 1 试 验 混凝土自收缩是指混凝土拌合物在初凝之后恒温恒重 1.1 原材料 下产生的宏观体积降低。由于混凝土自收缩主要发生在早 （1）水泥：P.O 42.5 海螺牌水泥，化学成分见表 1。 期，而此时混凝土还没有获得足够高的强度，即使较小的 表 1 水泥的化学成分