绍兴市古越酒厂废水处理工艺设计本科毕业设计说明书.docVIP

内蒙古科技大学 本科生毕业设计说明书 题 目： 学生姓名： 学 号： 专 业： 班 级： 指导教师： 绍兴市古越酒厂废水处理工艺设计 摘 要 本设计为某黄酒废水处理设计设计程度为初步设计。黄酒废水水质的主要特点是含有大量的有机物，属高浓度有机废水，故其生化需氧量也较大。该啤酒废水处理厂的处理水量为3000，不考虑远期发展。原污水中各项指标为：BOD浓度为5500mg/L，COD浓度为7200mg/L，SS浓度为4175mg/L，PH为4.14。 经分析知该处理水质属易生物降解又无明显毒性的废水，可采用两级生物处理以使出水达标。一级处理主要采用物理法，用来去除污水中的悬浮物质和无机物。二级处理主要采用生物法，包括厌氧生物处理法中的UASB法和好氧生物处理法中的SBR法，可有效去除污水中的BOD、COD。本设计工艺流程为： → 格栅 → 污水提升泵房 → 平流沉淀池 → 调节池 → → SBR池 → 因该废水BOD值较大，不经处理会对环境造成巨大污染，故要求处理后的排放水要严格达到国家二级排放标准，即：BOD≤30mg/ L，COD≤150mg/ L，SS≤70mg/ L，PH 6～9 。 。 ……………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………………关键词：废水 高浓度有机废水 UASB SBR Shaoxing Yue Winery Wastewater Wreatment Wrocess Wesign Abstract This design for a wine wastewater treatment design, design for the preliminary design level. The main features of wastewater quality wine is rich in organic matter, a high concentration organic wastewater, so the BOD as well. The brewery wastewater treatment plants water is 3000, without regard to long-term development. Indicators in the raw sewage as: BOD concentration of 5500mg / L, COD concentration of 7200mg / L, SS concentration of 4175mg / L, PH 4.14. The analysis of the process water is known to readily biodegradable no obvious toxic waste, can be two biological treatment to effluent standards. A process mainly uses physical method, used to remove suspended matter in sewage and inorganic. Mainly biological secondary treatment, including biological treatment in anaerobic UASB and aerobic biological treatment method in the SBR method can effectively remove sewage BOD, COD. The design process: Wastewater → grill→ advection sedimentation tank → regulation pool→ UASB reactor → SBR tank → water Because of the effluent BOD values greater without treatment would cause enormous environmental pollution, and called for the treated effluent to strictly meet the national emission standards, namely: BOD