年产80万方商品混凝土搅拌站设计毕业设计说明书.docVIP

毕业设计说明书 专 业 无机非金属材料工程 摘要 本设计的题目为年产80万立方米商品混凝土搅拌站。设计的主要工作是，配合比计算、设备选型、经济效益分析等。为满足年产80万方的需要，本搅拌站选择了JS1500型双卧轴强制式搅拌机，螺旋输送机选择了LS400，骨料配送机PLD1200，水泥筒仓为300T。 本设计的主要宗旨是高效、节能、环保等特点，本设计为全封闭骨料堆场，它的设计极大的降低了粉尘和噪音的污染。而且将砂石料含水量受天气影响降到最低，解决了冬季施工因砂子产生冻块对混凝土质量造成的影响，节省人工，减少工人的劳动强度。由于料场封闭后的保温作用还降低了冬季搅拌水电加热费用，节约了能源消耗。 另外，为解决搅拌站长期困扰的车辆洗刷水和混凝土残渣回收问题，本设计车辆的清洗问题。把混凝土残渣中砂石和水泥浆分离，实现了砂石再利用，达到无污染水废物排出充分利用的目的。 关键词：混凝土 配合比 搅拌机 配料 Abstract The topic of this design for the annual output of 800000 cubic meters of commercial concrete mixing station.Main work is design, mixture ratio calculation, equipment selection and economic benefit analysis, etc.To meet the needs of the annual output of 800000 square, the mixing station chose JS1500 dual-axial mixing machine, screw conveyor chose LS400, PLD1200 aggregate distribution machine, cement silo is 300 t. The main purpose of this design is the characteristics of high efficiency, energy saving, environmental protection, the design is fully enclosed aggregate yard, it greatly reduces the design of dust and noise pollution.And minimize ballast water content affected by weather, solve the winter construction because of the sand producing frozen blocks the effects on the quality of concrete, save manpower, and reduce the labor intensity of workers.Due to the effect of heat preservation of the yard closed after lowering the stir in winter heating, water and electricity fee, saves the energy. In addition, to solve the concrete mixing station long plagued vehicle washing water and waste recycling problem, the design of the vehicle cleaning problem.The sand and cement in concrete residue separated, the sand recycling, achieve the goal of non-pollution water wastes to make full use of. Keywords: concrete mix mixer ingredients 目录 摘要 I Abstract II 前 言 1 第一章 混凝土配合比的计算 4 1.1设计条件 4 1.2普通混凝土配合比计算 4 1.2.1确定配置强度 4 1.3确定水胶比 5 1.3.1回归系数 5 1.3.2胶凝材料28d胶砂抗压强度 5 1.3.3水泥28d胶砂抗压强度 6 1.4单位用水量 7 1.5胶凝材料、矿物掺合料、外加剂和水泥用量 8 1.5.1单位胶凝材料用量 8 1.