制药工程专业英语课文翻译.docVIP

Unit 1 Production of Drugs ???? About 5000 antibiotics have already been isolated from microorganisms，but of these only somewhat fewer than 100 are in therapeutic use. It must be remembered，however，that many derivatives have been modified by partial synthesis for therapeutic use;some 50，000 agents have been semisynthetically obtained from户lactams alone in the last decade. Fermentations are carried out in stainless steel fermentors with volumes up to 400 m3. To avoid contamination of the microorganisms with phages etc. the whole process has to be performed under sterile conditions. Since the more important fermentations occur exclusively under aerobic conditions a good supply of oxygen or air(sterile)is needed. Carbon dioxide sources include carbohydrates，e. g. molasses，saccharides，and glucose. Additionally the microorganisms must be supplied in the growth medium with nitrogen-containing compounds such as ammonium sulfate，ammonia，or urea，as well as with inorganic phosphates. Furthermore，constant optimal pH and temperature are required. In the case of penicillin G， the fermentation is finished after 200 hours，and the cell mass is separated by filtration. The desired active agents are isolated from the filtrate by absorption or extraction processes. The cell mass，if not the desired product，can be further used as an animal feedstuff owing to its high protein content. 关于5000抗生素已经分离出的微生物，但其中只有不到100有些治疗使用。必须记住，但是，许多衍生工具已被用于治疗使用部分合成修改;约50,000剂已被semisynthetically取得户内酰胺在过去十年孤独。发酵都是在不锈钢发酵罐出来的量高达400立方米。为了避免与噬菌体等微生物污染的全过程都必须在无菌条件下进行。由于更重要的发酵只发生在有氧条件下的氧气或空气好电源（无菌）是必要的。二氧化碳的来源包括碳水化合物，大肠杆菌克糖蜜，糖和葡萄糖。另外必须提供的微生物在与含氮如硫酸铵，氨水或尿素化合物生长介质，以及与无机磷酸盐。此外，不断最适pH和温度是必需的。在青霉素G的情况下，发酵完成200小时后，细胞的质量是由过滤分离。所需的活性剂是隔离的滤液吸收或提取工艺。大规模的细胞，如果不理想的产品，可进一步用作动物，由于其蛋白质含量高的饲料。? By modern recombinant techniques microorganisms have been obtained which also allow production of peptides which were not encoded in the original genes. Modified E. coli bacteria make it thus possible to produce A- and B- chains of hum