2010款迈腾雨刷洗喷水失效图解检修.docVIP

2010款迈腾雨刷清洗喷水失效图解检修 (2010-11-16 22:54:44) 转载 标签： 分类： 故障现象：2010款迈腾雨刷清洗喷水失效，操纵雨刷各档位工作正常。 故障检修： 用VAS5051检查网关内中央电器单元内有一个故障码存储：00897 挡风玻璃清洗泵V5对正级短路；读取09-02区显示为接通，说明J519能正常接收到开关操作信号，做执行自诊断，喷水电机继电器不动作，说明故障在执行线路。可能的原因：中央电器单元，喷水电机，喷水电机继电器和相关线路。 ? 由迈腾喷水工作原理可知，V5受控于中央电器单元J519，J519获取雨刷开关的操作信号，通过继电器J729控制V5是否工作。对于继电器J729的接线方式电路图并未给出具体的路线，只有摸着石头过河了。喷水电机V5共有两个插脚，拔下电机插头，在点火状态下，测量T2/1脚的黑/蓝线有15正实电，测量T2/2脚的绿/黄线无15正实电，（正常值在非工作状态，两插头为都有12V的同电势）。再对V5控制继电器进行检测，实测无工作时的吸合音，图为标注为404继电器，采用五脚控制模式。继电器的内部电路和维修厂家线路图是不一样的，结合继电器壳体上印刷的电路图分，3号脚接继电器的执行电路输入脚，非工作态和4脚常接触（相当于接通15电），工作态时与5号脚相连接，实现J519控制接地状态，而实测到4号脚输出到喷水泵电机并没有12V电，在检测继电器的3号脚为正常供电输入而4号脚无正常供电输出后，初步可说明继电器内部电器件存在故障。拔下继电器，直接测量继电器的1脚和2脚为继电器的控制电阻，实测为75欧，为正常的电阻，说明继电器的控制部分线路正常。脱去继电器外壳，发现和继电器3号脚连接的选择性触点片未正确安装，触点片本应夹在4脚和5脚接线区之内，而实际位置却在4脚和5脚接线区背板之外，如此受继电器外壳外力挤压作用时，外部的触点片和1号脚和2号脚接触。如此，使J519电控单元识别到控制端电压高而报出喷水线路对正极短路故障。将弹簧片回拉，重新插回4脚和5脚触点板之间，装复试车，故障排除。 rapid development of the market economy environment to explore public servants duty consumption monetization reform has provided a good foundation. The socialization of rear service work has been launched, and rapid progress in some places and departments, duty consumption monetization of carrier and approach to management has been resolved. Third, in recent years, exploring the monetization of duty consumption has made some progress, have gained some experience and can provide reference to the comprehensive reform of the system of public servants duty consumption further. Implementing an honest canteen, standardize official entertaining management; enhancing the telecommunication expense management; elimination of County travel and countryside subsidies; research village officials capitalization management of corporate spending, and so on. Finally, group ... 　　18 session to be held in Beijing from November 9, 2013 to 12th. 35 years ago blew the third plenary session of the reform and opening up in the spring breeze, changed, affect the world; today, 35 years later, in the eyes of