毕业设计(论文)－预热器堵塞的原因分析及预防处理措施.docVIP

摘要 洛阳理工学院毕业设计（论文） PAGE IV PAGE 4 预热器堵塞的原因分析及预防处理措施 摘 要 悬浮预热器的构成由旋风筒和连接管道(换热管道)，具有使气、固两相能充分分散均布、迅速换热、高效分离等功能，预热系统的控制对水泥的烧成有着重要的影响。预热系统堵塞,不仅会扰乱窑的热工制度,降低熟料产量和质量,影响窑的运转率,而且处理起来费时费力,甚至对人身安全造成危害。所以，预热系统要以预防为主，根据预热系统的工艺特点、装备水平，制定相应的操作规程，正确处理预热器、分解炉、回转窑和冷却机之间的关系，稳定热工制度、提高热效率、实现优质高产低耗和长期安全运转的生产目的。本文就生产中窑的预分解系统易出现的问题，特别是预热器结皮堵塞问题做了初步的综合分析，提出了一些解决办法。 关键词：预热器，结皮堵塞，预防处理措施 Preheater of prevention and treatment measures are analyzed ABSTRACT Suspension preheater composition by cyclone cone and connection (heat pipe), a contentious, solid two-phase can fully scattered uniformly, rapid, efficient heat function such as separation, the control system of cement firing has important influence. Preheat system, not only would disrupt the clogging of the kiln, reducing thermal clinker yield and quality, the influence of the kiln, and deal with amounts of time-consuming, even safety hazard. Therefore, the system of prevention, according to the technological characteristics, preheating system equipped level, formulate the corresponding operation procedures, correctly handle the preheater, decompose kiln stove, and cooling machine, the relationship between thermal system, improve the stability of high production efficiency, low consumption and long-term safety operation of production purposes. Based on the production of kiln precalcining system of the problem, especially the preheater and jam the comprehensive analysis, and puts forward some solving measures. KEY WORDS: Pre-heater, Mantle jamming，Prevention processing measure 前言 目　录 TOC \o 1-3 \h \z \u HYPERLINK \l _Toc263495284 前　言 PAGEREF _Toc263495284 \h 1 HYPERLINK \l _Toc263495285 第1章 预热器 PAGEREF _Toc263495285 \h 3 HYPERLINK \l _Toc263495286 1.1 预热器的换热功能 PAGEREF _Toc263495286 \h 3 HYPERLINK \l _Toc263495287 1.2 预热器的操作要求 PAGEREF _Toc263495287 \h 3 HYPERLINK \l _Toc263495288 第2章结皮堵塞 PAGEREF _Toc263495288 \h 5 HYPERLINK \l _Toc263495289