油公司检查易被查到的缺陷.docVIP

石油公司检查中常见的缺陷、 VIQ的规定及如何改正 缺陷： IOPP证书的格式B表内容不全，有关机舱的污水处理仅有油泥舱的油泥保存和处理，没有写明油污水舱的容积。 VIQ：Are the bilge and sludge tanks being recorded in Part 1 detailed in Form B of the IOPP Certificate? 污水舱和油泥舱是否如IOPP证书的格式B中所记载的被记录在油类记录薄第一 部分内。 Holding tank: m3 Sludge tank: m3 Other: m3 集油污水舱 油泥舱 其他舱 Details of the size of bilge and sludge tanks can be obtained from Form B of the IOPP Certificate, and the recording of the information here is only for the inspector to compare those details with the Oil Record Books if so desired. 污水舱和油泥舱的大小可以从IOPP证书的格式B中查到,这些资料的记录供检查官比较其与油类记录薄中的记载是否一致. 改正: IOPP证书中应该写清各使用的油舱，船上所有的油类作业必须记入油类记录薄。 油类记录薄中所使用的油舱应与IOPP证书格式B中所描述的油舱相符. 缺陷：船上的溢油演习没有按照SOPEP中规定的项目进行（如：油舱满溢、过度倾斜、 搁浅、碰撞等）。 VIQ：Is an approved MARPOL Shipboard Oil Pollution Emergency Response Plan (SOPEP) on board, and are drills regularly held and recorded? (6.1) 经认可的防油污应急反应计划是否在船，演习是否按常规进行并有记录？ 改正: 溢油演习应按SOPEP中的规定定期进行，以检验防油污计划是有效的。 缺陷：船上没有增强性检验报告。 VIQ：Is an Enhanced Survey Report File maintained on board? (7.1) 增强性检验报告的卷宗是否保持在船？ This requirement became mandatory on 6 July, 1995 for crude tankers of 20,000 dwt and above, and product tankers of 30,000 dwt and above, over five years old. 本项对于船令超过五年的20,000载重吨及以上的原油船和30,000载重吨及以上的成品油船自1995年7月6日起成为强制性要求. VIQ: Does the file contain a survey planning document and was it issued at least 12-15 months prior to the completion date of the last periodic survey? 卷宗是否包括了一个检验计划文件,并且是在上一次期间检验完成日期以前至少12-15个月签发的? VIQ: Does the file contain reports of structural surveys based on annual, intermediate and periodical surveys? 卷宗是否包括了以年检,中间检验和循环检验为基础的结构检验报告? VIQ: Does the file contain a Condition Evaluation Report issued on completion of the last periodical survey? 卷宗是否包括了一个在上次定期检验完成时签发的状况评估报告? VIQ: Does the file contain thickness measurement reports, as required for intermediate surveys (if deemed necessary) and periodical