腳手架JHA危险性分析.docVIP

Job Hazard Analysis Worksheet 工作危险性分析报告 Project / Company 项目/公司 MDI联合装置硝酸单元项目/ Date submitted 提交日期 Date Issued 签发日期 Job Description 工作描述 脚手架搭设 / 拆除 Reviewed By 审核人： Signature Date 签名 日期 Location 位置 Approved By 批准人： Signature Date 签名 日期 Analysis By 准备人 Name姓名: Position职位: Signature签名: Revision By 修订人： Signature Date 签名 日期 Equipment / Tools / Material to be used使用的工具/设备/材料 板手 钢管 跳板 踢脚板 管扣 垫板 Revision No 版次 Date of Revision 修订日期 Sequence of Basic Job Steps 基本工序 Identified HSE Hazards 确定的HSE危险 Precautions / Controls / By Whom 预防/控制措施/执行人 脚手架钢管装车 steel tube of Scaffold loading 手、脚砸伤 Spueeze hand and feet sand injured 正确使用个人防护用品。 Use PPE strictly. 装车过程中作业人员互相关照，动作一致。 Construction staff care for each other and consistent activities 脚手架材料的运输 Scaffold material conveyance 装车的架杆超长、超高，在行驶中容易发生交通事故、人员伤害 Overlong and height scaffold pole can cause to Traffic accidents. 装车的架高不能超过车厢长度；运输车辆的车厢长度要大于6米，架杆的高度不能超过车厢的高度； The height of scaffold should not surpass the length of truck and the minimum length of truck is 6 meters, The height of scaffold should not surpass the height of the truck . 行车前检查车辆状况，确保车况完好； The truck should be checked to keep a good state before it be used. 车辆在行驶中严格遵守交通法规； Traffic order should be obeyed in transportation. 进入施工现场限速15Km/小时； The maximal speed is15Km/h in the site. 运输架杆的车上严禁乘人。 The truck which used to carry piles should not carry human being. 脚手架的搭设 Scaffold installation 架杆、扣件砸伤手、砸伤脚 hurt hand s or feet by scaffold pole or clips 作业人员戴好防护手套，穿好防护鞋。 Wear protective gloves and safety shoes 架子搭设必须由持有特殊工种上岗证的架子工专人搭设； Only qualified scaffold erectors are permitted to erect ,modify or dismantle scaffolds. 作业过程中作业人员互相关照，动作一致，递送扣件不能抛掷； The staffs care for each other and consistent activities .Pro habit delivery clips with method of throwing. 工作时，使用工具袋存放工具； Put the tools in the tool bags when working. 设踢脚板，不准遗留工具等杂物； Establish kick-off board and not permit t