脂肪酶产生菌发酵条件的优化..docVIP

绵阳师范学院 本科生毕业论文（设计） 题 目 专 业 生 物 技 术 院 部 生命科学与技术学院 学 号 姓 名 杜 长 蔓 指 导 教 师 李 俊 刚 答 辩 时 间 论文工作时间：2011 年 7 月 至 2012 年 5 月 脂肪酶产生菌M-6-2发酵条件的优化 学 生：杜长蔓 指导老师：李俊刚 摘 要：本文对绵阳师范学院微生物实验室筛选和鉴定的产脂肪酶细菌M-6-2的生长动力学和产酶动力学进行了研究；通过单因素实验和正交试验，对脂肪酶产生菌M-6-2 摇床发酵产脂肪酶的培养基组成和培养条件进行优化，得出较佳的产酶培养基组成配方为：1.5%淀粉+0.5%酵母膏为碳源、 4.5%豆饼粉+1.5%硝酸铵为最佳的氮源、0.05%磷酸氢二钠和0.15%硫酸镁；最优的发酵条件为：初始pH7.5，接种量1.5 %，装液量20ml/250ml，发酵温度35℃，在转速180r/min下，培养16h，经过优化后发酵液脂肪酶酶活力最高可达到15.60 U/ml,较优化前提高了49.57%。脂肪酶产生菌M-6-2与国内文献报道的产脂肪酶细菌相比产酶活力高。对该菌株发酵条件进行优化后，为生产性试验打下了基础 关键词：脂肪酶产生菌M-6-2脂肪酶；发酵；优化 Lipase to produce bacteria M-6-2 Optimization of fermentation conditions Undergraduate: Du Changman Supervisor: Li Jun Gang Abstract: In this paper, Laboratory screening and identification of lipase production by bacteria in the M-6-2 growth kinetics and enzyme production kinetics were studied; through single factor experiments and orthogonal test, the lipase to produce bacteria M-6-2 shaker fermentation lipase medium composition and culture conditions were optimized to come to a better enzyme production medium composition formula: 1.5% starch and 0.5% yeast extract as carbon source, 4.5% of the soybean powder and 1.5% ammonium nitrate for the best source of nitrogen, 0.05% disodium hydrogen phosphate and 0.15% magnesium sulfate. Optimal fermentation conditions were: initial pH 7.5, 1.5% of the inoculum size, liquid volume 20ml/250ml, fermentation temperature 35 ° C, in the speed 180r/min next, cultured 16h After optimization of the fermentation broth lipase activity can reach 49.57% to 15.60 U / ml, compared to before optimization. Lipase to produce bacteria M-6-2 and reported in China in the production of lipase bacteria compared to the high activity of enzyme production. Of the strain fermentation conditions optimized, laid the foundation for th