O2CO2气氛下CH4再燃还原NOz的实验研究.pdfVIP

中国工程热物理学会 燃烧学 学术会议论文 编号：094027 O2/CO2 气氛下 CH4 再燃还原 NOx 的实验研究 谢 芳，张 军，盛昌栋，张永春，陈 洁 (东南大学热能工程研究所 , 南京 210096) （电话Email：xiefang2007@163.com） 摘要：O2/CO2 燃烧技术与气体再燃协同是实现 NOx 高效减排的一种重要手段。在自行设计的实验装置 上研究了 CH4 再燃还原 NOx 的特性。主要研究结果表明，最佳再燃温度约为 1000℃，再燃区最佳停留 时间在 0.4～0.6S 之间，随着平衡比的增大脱硝率最高可达 90%以上，烟气中初始 NO 浓度越大其脱硝 率越高，而 SO2 存在时则对 NO 的还原产生不利影响。并且 O2/CO2 气氛比常规空气气氛更有利于 NO 的脱除. 关键词：O2/CO2；再燃；NOx；脱除率 Experimental Study on NO Reduction by CH4 Reburning in O2/CO2 Mixture XIE Fang,, ZHANG Jun, SHENG Chang-dong, ZHANG Yong-chun, CHEN Jie (Thermal Energy Engineering Research Institute, Southeast University, Nanjing 210096, China) （TELEmail：xiefang2007@163.com） Abstract: The way of reburning cooperated with O2/CO2 is one of important technologies to reduce NOx more efficiently. In this study, systematical experiments on the release of NOx by CH4 reburning under different conditions were carried out. Resulta of the experimenta show that the optimum temperature of reburning is 1000℃,the optimum range of resident time in the reburning area is 0.4～0.6S,the NO removal efficiency increase with the stoichiometry ratio,and the highest is up than 90%,the inlet NO content increase has advantage effect on NO reduction while the SO2 has disadvantage effect. And so on ,the results shows comparing with conventional air condition, the cooperated way was propitious to reduce NO. Key words: O2/CO2; reburning; NOx；destruction ratio 引言 电厂煤粉锅