固硫灰与磨细固硫渣复掺用作混凝土掺合料的试验研究.pdfVIP

学兔兔 2015年第 12期 混 凝 土 与水 泥制 品 2015 No．12 12月 CHINA CONCRETE AND CEMENT PR0DUCTS December 固硫灰与磨细固硫渣复掺用作 混凝土掺合料的试验研究 邓天明 ，张凯峰 ，孟 刚 ，刘文欢 ，冯绍航 ，邹月超 (1．中建西部建设北方有限公司，西安710065；2．西安建筑科技大学，710055；3．陕西省建筑科技重点 实验室，西安710055；4．陕西华电瑶池发电有限公司，咸阳713500) 摘 要：试验将循环流化床燃煤固硫灰与磨细固硫渣按不同比例复掺，分析了复掺灰的各项性能，研究了复掺 灰等质量替代粉煤灰对混凝土工作性能及强度的影响。结果表明，复掺灰安定性合格，固硫灰占比增大，复掺灰活性 指数先增大后减小，需水量比逐渐增大，占比为40％时活性指数最高为84．23％，占比≤50％时，需水量比满足Ⅱ级灰 要求；采用减水与保坍比例为1：O．8的高保坍减水剂，固硫灰占比40％的复掺灰配制的混凝土工作性能及强度均优 于粉煤灰混凝土。与C30混凝土相比，复掺灰对C60混凝土的强度特别是早龄期强度的贡献更大。 关键词：磨细固硫渣；掺合料；工作性能；强度；高保坍 Abstract：Circulating fluidized bed coal combustion fly ash(CFBCF)and ground slag(GCFBCS)were admixed and the properties of the admixture were analyzed．The equal mass replacement of fly ash by admixture and its effects on workabilitv and the strength of the concrete were also studied．The experimental results show that the soundness of admix— ture is qualified，the index of activity 0f admixture increases first and then decreases with increase of the FBCF ratio，on the other hand．water demand ratio increases gradually．The maximuria index of activity is 84．23％ with the 40％ FBCF ra— tio．the water demand ratio meet requirement of FA Ⅱ when the ratio is less than 50％．The workability and strength of concrete made of water reducer which ratio of water reducing agent and slump retaining agent is 1：0．8 and admixture which FBCF ratio is 40％ is better than nv ash concrete．Compared with C30 concrete．the admixture contribution to strength especially e