混杂纤维对客运专线早强型支座灌浆料的增韧作用.pdfVIP

学兔兔 斩 建魄 中国科技核心期刊 混杂纤维对客运专线早强型支座 灌浆料的增韧作用 马保国，朱艳超，胡迪，李海南 (武汉理工大学 硅酸盐建筑材料国家重点实验室，湖北 武汉 430070) 摘要：通过测试掺入纤维的早强型支座砂浆的抗压强度、抗折强度、劈裂抗拉强度、弹性模量和韧性指数，研究了混杂纤维对早 强型支座砂浆的增韧效果。结果表明：掺入纤维可以提高砂浆的抗压强度，显著提高了砂浆的抗折强度、劈裂抗拉强度和弹性模量。 混杂纤维的最佳掺入比例为0．6％钢纤维+0．2％玻璃纤维+0．2％聚丙烯纤维，使砂浆28 d的抗压强度、抗折强度、劈裂抗拉强度和弹 性模量分别提高-7％、68％、44％~fl 53％，压折比从空白样的6．35降低到4．03，大大提高了砂浆的韧性指数，增强了砂浆的韧性。 关键词：钢纤维；聚丙烯纤维：玻璃纤维；混杂纤维，增韧作用 中图分类号：TU528 文献标识码：A 文章编号：1001—702X(2013)07=0011-05 High toughness characteristics of early strength grouting mortar reinforced with hybrid fibres MA Baoguo，ZHU Yo,n~hclo，HU Di，LI Hainan (State Key Laboratory of Silicate Materials for Architectures，Wuhan University of Technology，Wuhan 430070，Hubei，China) Abstract：An experimental study was conducted on early strength grouting mortar reinforced with fibres．The compressive strength，flexural strength，splitting tensile strength，static modulus of elasticity and toughness indices were determined to study the effect of the hybrid fibres on the properties of early strength grouting m0r【 ．The results showed that incorporation of fibers can improve the compressive strength，and significantly improve the flexural strength，splitting tensile strength and modulus of elasticity． Hybridization of fibms in the quantities of 0．6％ steel fibres+0-2％ glass fibres+0．2％ polypropylene fiber was the best mixing ra- tio，enhanced the compressive strength，fiexural strength，splitting tensile strength and static modulus of elasticity of the early strength grouting mol~ar by about 7％，68％，44％ and 53％ respectively，the ratio of compressive strength an