脱硫石膏基赜涂石膏砂浆的配制技术及应用研究.pdfVIP

学兔兔 全 国中文核心期刊 钎 建蟓 中国科技核心期刊 脱硫石膏基赜涂石膏砂浆的 配制技术及应用研究 许霞，吴开胜，李龙梓 (江苏尼高科技有限公司，江苏 常州 213141) 摘要：通过试验分析了轻质骨料、保水剂、触变剂等对脱硫石膏基喷涂石膏砂浆抗压强度、拉伸粘结强度、保水率、施工性的影 响，确定了脱硫石膏基喷涂石膏砂浆的配比为：脱硫石膏50％，轻骨料玻化微珠 3％，细砂46．4％，保水剂纤维素醚O．2％，石膏缓凝 剂 O．25％，触变剂淀粉醚0．05％。制备的脱硫石膏基喷涂石膏砂浆初凝、终凝时间分别为 85、104min，抗折、抗压强度分别为2．3、4．7 MPa，与混凝土板和加气混凝土砌块的拉伸粘结强度分别为0．45、0．37MPa。并在实际工程中得到应用 。 关键词：脱硫石膏；石膏砂浆；喷涂：施工性 中图分类号：TU56~4．5 文献标识码：A 文章编号：1001—702X(2016)01—0004—03 Study on preparation technology and application ofdesulfurization gypsum plastermortar XU Xia， U Ksheng，LILongzi (JiangsuNIGAO TechnologyCo．Ltd．，Changzhou213141，China) Abstract：Effectoflightweightaggregate，waterretention agent，thixotropic agenton thecompressive strength，tensile bond strength，waterretention rate and workabilityofdesulfurization gypsum—based plastermortarwasanalyzed through experimenta1．The proportion ratio ofdesulfurization gypsum—based plastermortarwasdetermined asfollows：50％ desulfurization ygpsum，3％ glass beadsoflightweightaggregate，46-4％ find sand，O_2％ waterretention agentofcelluloseethers，O．25％ gypsum retrader，and 0．05％ thixotropic agentofstarch ether．The initialsetting and final setting time ofthe prepraed desulfurization gypsum-based plaster mortarwere 85min and 104min respectively，flexural and compressive strength were 2．3MPa and 4．7MPa respectively，and the tensile bond strength of the concrete slab and aerated concrete block wereO．45MPana d O．37MPa respectively．Ithasbeen appliedin practical engineering． Key words：desulfurizationygpsum，plastermortra，spraying，eonstmetability