滚动活塞压缩机双级压缩中间补气制冷热泵系统的实验研究.pdfVIP

Vo1. 40 No.3 第 40 卷第3 期 北京工业大学学报 JOURNAL OF BEIJING UNIVERSITY OF TECHNOLOGY Mar. 2014 2014 年 3 月 滚动活塞压缩机双级压缩中间补气制冷/热泵 系统的实验研究 许树学，马国远，刘 琦，刘中良 (北京工业大学环境与能源工程学院，北京 100124) 摘 要:通过对带补气的双级压缩制冷/热泵系统性能的分析计算，确定出制冷与制热工况下最佳高低压腔容积比 的范围.依据计算结果设计出样机进行实验研究.结果表明:与单级压缩的系统比，带补气的双级压缩系统的制冷 量提高 5% -157毛，制冷能效比(energy efficiency ratio ,EER) 提高 10% 斗2%;0.5-3 C蒸发温度下制热量能达到 额定工况制热量的 92% -95% ;双级压缩中间补气的系统能有效遏制超低温下制热量的衰减， - 27.6 - - 26. 1 c 下的制热量为额定工况的 587串. 关键词:双级压缩;热泵;补气;滚动活塞压缩机 中图分类号: TM 925. 1; TU 83 1. 7 文献标志码:A 文章编号: 0254 -0037(2014)03 一 0418 -05 Experimental Study on Vapor Injection Refrigeration System With Two-stage Rolling Piston Compressor XU Shu-xue , MA Guo-yuan , LIU Qi , LIU Zhong-liang (College of Environmental and Energy Engineering , Beijing University of Technology , Beijing 100124 , China) Abstract: An analysis model on the two-stage compression refrigeration/heat pump system with vapor injection system was set. The optimal volume ratio of high-pressure cylinder to low-pressure had been discussed under both cooling and heating conditions. On this basis , prototype was set up and experimental studies had been done. The results show that , compared with single-stage compression system , the cooling capacity and cooling EER( energy efficiency ratio) can increase 5% -15% and 10% -129毛， respectively; the heating capacity with evaporating temperature ranging from O. 5 to 3 c is 92% - 95 % of that under the rated condition , and 58 % of that under the rated condition when evaporation temperature is between - 27. 6