奥威发动机故障解析一(外国英语资料).docVIP

奥威发动机故障解析一 A 2010-01-19 19:35 Aowei engine fault analysis of the first few days, there is a Aowei tractor engine model 6DL1-31, the engine coolant of the car It is without rhyme or reason. disappeared, has been running about 400000 kilometers, initially suspected to be water because of aging and lost the water sealing effect, remove the oil pan and the coolant no, found the coolant water drop from the cylinder, as the coolant channel pressure is not enough, I added 1.5 pressure at the top of the expansion tank with the trachea, the result was not found to occur, what is the reason? Could it be that the situation is affected by temperature? It should be the cylinder pad fault, so I remove the cylinder head, cylinder pad found two cylinder middle position does have a lot of traces of water, because there is a section between 6DL series engine cylinder and cylinder, cylinder pad if not tight, the coolant may be discharged along the section. Moreover, the exhaust pipe on the contact surface there are traces of coolant, so it is only to replace the cylinder pad again, but to tell the truth, the heart there is a kind of fault as the source of this is not the feeling, but also in the comfort of their own, currently found no other problems, first ok! After the change after the engine cylinder pad, and other problems, the fire engine, similar knocking sound, refueling doors do not add, after flameout, loosen the cylinder high-pressure pipeline, start the engine, fuel injection pressure also, the eye view is also good, is the diesel oil filter is dirty, unloading a look inside half water half of the diesel engine can work normally do. At that time, with the owners joked: how to change the engine, boiling water, burning oil, in which the oil ah, there are all the water, I put the box of diesel oil drain off, before the release of half a bucket of water, the owner asked me, this oil can use it I said at the time, can not be used, it must be fragmented to Riga precipitation can