Co2+替代对NiCuZn铁氧体电磁性能的影响-磁性材料及器件专业.PDF

工艺·技术·应用 Co2+替代对 NiCuZn 铁氧体电磁性能的影响 李旭哲，苏 桦，张怀武，师凯旋，顾卫卫 （电子科技大学电子薄膜与集成器件国家重点实验室，四川成都 610054 ） 摘 要：采用固相反应法制备了低温烧结 NiCuZn 铁氧体，研究了 Co2+替代量对铁氧体材料显微结构、饱 和磁感应强度、矫顽力以及在偏置磁场下磁导率和品质因数的影响。研究表明，对于低磁导率的 NiCuZn 铁氧 体，适量 Co2+替代可对铁氧体负的磁晶各向异性常数进行补偿，能在一定程度上提升材料的磁导率。在大直流 偏置场的作用下，铁氧体的磁导率都出现明显的下降，而矫顽力是决定其增量磁导率的主要因素。 关键词：NiCuZn 铁氧体；磁导率；直流叠加；Co2+替代 中图分类号：TM277+.1 文献标识码：B 文章编号：1001-3830(2010)05-0034-03 2+ Effect of Co Substitution on the Electromagnetic Properties of Low-temperature-fired NiCuZn Ferrites LI Xu-zhe, SU Hua, ZHANG Huai-wu, SHI Kai-xuan, GU Wei-wei State Key Laboratory of Electronic Films and Integrated Devices, University of Electronic Science and Technology of China, Chengdu 610054, China Abstract ：In this paper, low-temperature-fired NiCuZn ferrites were prepared by solid-state reaction method. The effects of Co2+ substitution on microstructure, saturation magnetic flux density, coercivity and permeability ， Q-factor under DC-bias-superposition field were investigated. It was found that proper content of Co2+ substitution could compensate the negative magnetocrystalline anisotropy constant of the ferrite and resultantly lead to the increase of permeability. Permeability continuously decreases with increasing DC-bias-superposition field. And the incremental permeability of the material under high DC-bias-superposition field is mainly dependent on its coercivivity. Key words: NiCuZn ferrite; permeability; DC-bias superposition; Co2+ substitution 要在 NiCuZn 铁氧体中掺杂各种低熔氧化物或低 1 引言