东风4检查（Dongfeng 4 inspection）.doc

东风4检查（Dongfeng 4 inspection） Report: XXX is engaged in the operation workshop XXX of the dongfeng 4 type of diesel engine drivers to inspect the oil, please indicate. Guide tools: pistol oil pot, flashlight, cotton yarn, cleaning needle, oil pot, oil drum, pressure pump. Stand at the beginning: stop the locomotive on the line with the trench, build the front and rear board, hit the stop wheel, keep the locomotive brake, pay attention to safety. Carry on the upper inspection of the locomotive: get in the car and pay attention to safety. II driver room (1), drivers room door: the locking device works well and the glass is broken. Oil hole in the door shaft. (2) fire extinguishers: should be complete and well sealed. (3) right side window: whether the action is flexible, whether the glass is broken or not. (4) the right type lamp: the bulb, the glass is broken, the wiring is loose. (5), right electric fan and front window: if the electric fan cover is complete, the glass is not broken. The action axis points to oil. (6) right side wiper: the small oil plug of the air cylinder is loose and lost. Manual and pneumatic test. Regularly press into lithium base fat. (7) on the right of the console: whether the switches are good. All the instruments are in good condition. (8) electric furnace: whether the furnace plate is full, the resistance wire is not broken, the bolt and the connection are good. (9) the wind pipe pedal switch: action test. (10) heat fan radiator: whether it is damaged, leaky, the exhaust valve is good. (open test) (11) headlight: back cover and card are firm. Whether the coil of the bulb and the secondary coil is burnt and the wiring is loose. (12) drivers room lamp: is there any damage? (13) speed table: is it good? (14), left electric fan and front glass window: whether the outer cover of the electric fan is complete, whether the glass is damaged or not. The shaft of the action is oil. (15) left wiper: the small oil plug of the air cylinder is loose and