余热锅炉事故处理规则（Waste heat boiler accident treatment rule）.docVIP

下载本文档

5
0
约 22页
2017-07-24 发布于河南
举报
版权申诉

余热锅炉事故处理规则（Waste heat boiler accident treatment rule）.doc

1、原创力文档（book118）网站文档一经付费（服务费），不意味着购买了该文档的版权，仅供个人/单位学习、研究之用，不得用于商业用途，未经授权，严禁复制、发行、汇编、翻译或者网络传播等，侵权必究。。
2、本站所有内容均由合作方或网友上传，本站不对文档的完整性、权威性及其观点立场正确性做任何保证或承诺！文档内容仅供研究参考，付费前请自行鉴别。如您付费，意味着您自己接受本站规则且自行承担风险，本站不退款、不进行额外附加服务；查看《如何避免下载的几个坑》。如果您已付费下载过本站文档，您可以点击这里二次下载。
3、如文档侵犯商业秘密、侵犯著作权、侵犯人身权等，请点击“版权申诉”（推荐），也可以打举报电话：400-050-0827(电话支持时间：9:00-18:30)。
4、该文档为VIP文档，如果想要下载，成为VIP会员后，下载免费。
5、成为VIP后，下载本文档将扣除1次下载权益。下载后，不支持退款、换文档。如有疑问请联系我们。
6、成为VIP后，您将拥有八大权益，权益包括：VIP文档下载权益、阅读免打扰、文档格式转换、高级专利检索、专属身份标志、高级客服、多端互通、版权登记。
7、VIP文档为合作方或网友上传，每下载1次，网站将根据用户上传文档的质量评分、类型等，对文档贡献者给予高额补贴、流量扶持。如果你也想贡献VIP文档。上传文档

余热锅炉事故处理规则（Waste heat boiler accident treatment rule）

余热锅炉事故处理规则（Waste heat boiler accident treatment rule） Three point one Phenomenon of water shortage 3.1.1 Water level is below normal. 3.1.2 The alarm has a low water level signal. 3.1.3 When the water shortage is serious, the superheated steam temperature rises or the temperature decreases and the water quantity increases. 3.1.4 The abnormal flow rate of water is less than the amount of evaporation (water wall tube or economizer pipe rupture, and water supply is greater than evaporation). Three point two Reasons for lack of water 3.2.1 The operator was careless and didnt monitor the water level or mistake it. 3.2.2 The malfunction of the water supply automatic regulator was not found in time. 3.2.3 The water level meter indicates incorrect operation of the operator. 3.2.4 Failure of water supply pipe or feed pump makes water pressure drop 3.2.5 Boiler blowdown valve leakage or discharge without contact and fire. 3.2.6 Water wall tube, convection tube or economizer pipe wall rupture. 3.2.7 The isolating valve core falls off on the water supply pipeline. Three point three Treatment of water shortage 3.3.1 When the boiler pressure and feed water pressure are normal, while the water level in the drum falls to the normal water level (i.e., slight water shortage), the following measures should be adopted: A. carries out the comparison of the water level meters and the cleaning of the drum water level gauge to check whether the instructions are correct. B. will automatically change the water supply to manual operation on the spot and increase the water supply. 3.3.2 As after treatment, the water level in the drum is still very low, should be closed all the boiler drain valve, and check whether the regular discharge valve and drain valve is closed, such as leakage serious, should be shut down the total discharge valve. 3.3.3 If the above measures are taken, the water level will continue to decline and the minimum allowable water level shall be reported to the workshop or th