液化石油气储罐焊疤表面裂纹的磁记忆信号研究.PDFVIP

2 67 Vol. 26 No . 7 2 0 0 4 7 NDT July 2 0 0 4 , , ( 中国特种设备检测研究中心, 北京 100013) : 采用磁记忆检测发现液化石油气储罐焊疤部位 在较强的磁记忆信号通过对储罐进行 0~ 4. 0MPa 的加载试验, 研究磁记忆信号的幅度和梯度随载荷的变化最后采用磁粉探伤复验发 现磁记忆信号部位 在大量3~ 5mm 长的焊疤表面裂纹试验结果表明, 在0~ 2. 0MPa 的加压过 程中, 磁记忆信号的幅度和梯度均逐渐增大, 到2. 0MPa 时达到峰值, 在2. 0~ 4. 0MPa 的加载过程 中迅速下降, 在此期间采用声发射监测, 发现了七 个声发射信号, 证明该部位应力产生了迅速释 放由此证明磁记忆信号的幅度和梯度既与材料所处的整体应力有关, 也与该部位的局部应力集 中度有关 : 金属磁记忆检测; 压力容器; 裂纹; 信号分析 :TG115. 28 : A : 2004) STUDY ON THE MAGNETIC MEMORY SIGNALS FROM THE WELDING SCAR SURFACE CRACKS OF LIQUEFIED PETROLEUM GAS TANK SHEN Gongtian, WU Yan, WANG Yong ( China Spe ial Equipment Inspe tion and Resear h Center, Beijing 100013, China) Abstra t: A typi al signal was found in the position of welding s ar of a liquefied petroleum gas( LPG) tank by metal magneti memory testing ( MMMT) . The amplitude and gradient of MMMT signals were investigated through pressurizing the tank from 0 to 4MPa. 3~ 5mm long surfa e ra ks were found by magneti parti le testing in the position of MMMT signals after pressurization. Results showed that the amplitude and gradient of MMMT signals in reased from 0 to 2MPa and qui kly de reased from 2 to 4MPa, and seven a ousti emission( AE) signals were monitored by AE instrument during the time. AE signals proved that stress release took pla e in the area. The amplitude and gradient of MMMT signals not only relied on the average stress of the shell, but also relied on the lo al stress on entration. Keywords:Metal magneti memory testing; Pressure vessel; Cra k; Signal analysis (MMMT) , 20 90 , 90