Workover Rig_Derrick 修井机.ppt

Mast Assembly井架总成 ?Main Characters主要特点: ◆∏-shape Mast 桅杆式井架 ◆Two parts telescoping Mast 井架为两节可伸缩式 ◆Single hydraulic cylinder raising and telescoping 单液缸起升、伸缩 ◆Mast section is rectangle and front split 井架截面为矩形、前开口式 ◆Equipped with cat cylinder and standpipe 配备吊钳油缸和立管 ◆ Working platform井口操作低平台 ◆Climbing Aid 助爬器 ?Technical Parameters主要参数: Height净高: 24m Max. load最大钩载: 750kN（75t） Tilt Angle倾角: 4.5o Traveling System游动系统: 4X5 Wire Rope大绳规格： φ26(1”) Max. Wind Load最大抗风力: 110km/h(60节） ?Mast working composition 井架工作状态图: ?Upper Mast井架上体: ?Lower Mast井架下体: ?Lock Pin Device锁销装置: This lock pin device is installed on the upper mast. When the mast reaches its designed position, the lock block will eject out and sit on the lower mast automatically to ensure the whole mast stand firmly. 本锁销装置安装在井架上体上，当井架上体伸到设计位置时，锁块自动弹出，锁在井架下体上，确保井架起立后稳定可靠。 ?Crown Blocks井架天车: Crown blocks is fixed with five sheaves(bottom diameter is ?525)天车上配备5个滑轮(底径?525) ： crown sheaves天车轮： 2个 Fastline sheave快绳轮： 1个 Deadline sheave死绳轮： 1个 Sandline sheave捞砂轮： 1个 ?Traveling System游动系统: Traveling system consists of traveling block,crown block,wire rope,etc.This system is 3X4, six lines structure.The dead end of wire rope is fixed to the wireline anchor according to JZ100 Instructions,the other end of rope is fixed to the main drum.游动系统由游车大钩等组成。本机为3×4结构，6股绳，钢丝绳的死端按《JZ100型指重 表使用说明书》固定在死绳固定器， 活端固定在主滚筒上。 ?Guylines Assembly绷绳总成: Guylines consists of four wind load guylines,two inner load guylines and two guylines from racking platform to ground.The left diagra