发电机定冷水系统含氢量高原因分析及处理.pdfVIP

内蒙 古 电力 技 术 2013年第31巷第3期 INNER MONGOLIA ELECTRIC POWER 9l doi：10．3969~．issn．1008-6218．2013．03．008 发电机定冷水系统含氢量高原因分析及处理 马 骋 。赵耀俊 郭 恒，訾 娟，王 锋， (神华内蒙古准格尔发电有限责任公司， 内蒙古 准格尔 010300) 摘要：神华内蒙古准格尔发电有限责任公司3号发电机运行中发现定冷水含氢量超标， 严重影响机组的安全稳定运行，对此及时采取 了对定冷水箱连续充氮等措施，将定冷水含氢 量控制在安全范围内。检修中通过保压查漏试验发现绝缘引水管接头处、底部排空堵头、线 棒、出线罩绝缘盒等部位存在漏氢现象，对此采取了焊缝补焊、更换O型圈、更换绝缘引水管 及线棒等措施，经处理后对其进行定子绕组严密性试验，漏气率为0．61％，达到合格范围，排 除了定冷水系统漏氢的故障。 关键词：发电机定冷水系统；漏氢；定子线棒；漏气率 文献标志码：B 中图分类号：TM623．3 文章编号：1008—6218(2013)03—0091—04 AnalysisofHigh Hydrogen Contentin GeneratorStator CoolingWaterSystem and ItsTreatment GuoHeng，ZiJuan，WangFeng，MaCheng，ZhaoYaojun (ShenhuaInnerMongoliaZhungeerPowerGenerationCo．，Ltd．，InnerMongolia Zhungeer 010300) Abstract：Excessive amountofcold hydrogen occured during operation ofthe set3 in Shenhua InnerMongolia Zhungeer PowerGeneration Co．，Ltd．，which seriously affected the unitS safe and stable operation．Therefore take a cold water tank for continuous fixed nitrogen and other measures thatwillbe cold hydrogen contentcontrolin a safe range． Overhaulby holding pressure leak testfound insulated waterpipejoints，bottom drain plug，wire rods，outletboxes and other pansofthe insulating coverpresence ofhydrogen leakage phenomenon， which took a seam welding， replace the O—type coil， replace insulating water pipes and wire rods and other measures to be treated stator winding eakage rate ofO．61％ ，reaching acceptable range，by which the hydrogen tightness test，1 leak fixed watersystem failureswereovercome． givenwatersystem ofgenerator；hydrogen leakag