大故障预防措施（Preventive measures for large faults）.docVIP

大故障预防措施（Preventive measures for large faults） Locomotive fire prevention, prevention of speed car and driving wheel slow measures In order to manage and use good play of the locomotive, and give full play to the maximum efficiency in the use of locomotive, the successful completion of the task of rail transport, cost savings, keep the unit development principle, formulated the measures, hope the relevant personnel to abide by the implementation. Fire safety measures for locomotive Management content and requirements 1, the locomotive crew member should be familiar with the performance and application method of the fire extinguisher on the locomotive. Check the number, the fire fighting equipment shift to the locomotive attachment of seals and the appearance of the situation. Should be replaced immediately after use or when the fire extinguisher is not working properly. 2, the locomotive cab, high-pressure chamber, mechanical and floor to keep clean, no grease, sundries. The diesel engine and the electric heater are forbidden to bake any articles, such as cotton thread, handle, etc., in a fixed and safe position. No smoking except drivers outdoor. When smoking in the drivers cab, the matches and cigarette butts must be put out in time and placed in the ashtray. 3, according to the provisions of the fuse, burning seriously record, for the burning of frequent parts, to identify the reasons, timely processing. Check battery regularly to eliminate leakage and loose connection. Check the motor, electrical appliance and electrical circuit regularly, tighten and loosen the contacts, bandage the damaged insulation, replace the damaged arc extinguishing cover, and eliminate the grounding, the virtual connection and the short circuit. It is strictly prohibited to add electrical wire and socket. 4, check all outbound protection device must be in good condition, no blind fault processing way to prevent the expansion of the accident; differential pressure gauge makes the diesel e