零电压导通零电压关断单管无线电能传输电源.pdfVIP

2015 年 2 月 电 工 技 术 学 报 Vol.30 No. 4 第 30 卷第 4 期 TRANSACTIONS OF CHINA ELECTROTECHNICAL SOCIETY Feb. 2015 零电压导通、零电压关断单管无线电能传输电源 1 1 2 2 王春芳 陈杰民 李 聃 孙 会 （1. 青岛大学自动化工程学院 青岛 266071 2. 海尔集团技术研发中心 青岛 266103 ） 摘要 基于一款新型单管互感耦合式无线电能传输电源，其开关管可同时实现零电压导通和 零电压关断。本文介绍了该电源的系统结构，论述了电能传输的工作过程及软开关的控制方式和 方法。采用互感模型法对主电路进行了建模，给出了其等效电路，推导了主电路的电压增益，并 绘制了电压增益随谐振网络参数变化的曲线。给出了一二次谐振频率的设定方法及二次输出电压 的控制方法。对所研究的新型无线电能传输电源进行了软开关实现、功率传输、效率及功率因数 等仿真，并制作了一台额定功率为 1kW 的样机，记录了功率传输过程中软开关及其控制波形，做 了效率和功率因数随一次、二次线圈位置变化等实验。仿真及实验表明了所提出的电路拓扑及其 控制方法的可行性和正确性。 关键词：无线电能传输 互感耦合 单管电源 零电压导通 零电压关断 中图分类号：TM131 A Zero-Voltage Turn-on and Turn-off Single-Switch IPT Power Supply Wang Chunfang1 Chen Jiemin 1 Li Dan2 Sun Hui2 （1. Qingdao University Qingdao 266071 China 2. RD Center of Haier Group Qingdao 266103 China ） Abstract A novel single switch inductive power transfer(IPT) power supply was proposed in this paper and its switch can achieve ZVS and zero-voltage turn-off at the same time. The system structure of this power supply was introduced. Working process of the power transfer and the control strategy of the soft-switching was analyzed in detail. By using the mutual inductance model method, the equivalent circuit could be obtained. Then the voltage gain of the main circuit could be deduced and the voltage gain characteristics were analyzed as the main parameters of the circuit vary respectively. The features of the primary and the secondary resonant frequency were discussed and the control method of output voltage was given. The simulation results of the soft-switching, power transmission, efficiency and