锅炉运行的十大认识误区（Ten misunderstandings of boiler operation）.docVIP

锅炉运行的十大认识误区（Ten misunderstandings of boiler operation） Boiler operation is a professional and highly technical work. Because of the quality of personnel engaged in this work, will inevitably result in this or that, here, the author to professional years of work experience, analysis of the following ten misunderstanding, so that the relevant person can clarify the vague understanding, improve the technological level of operation, to achieve safe and economic operation of the boiler unit. One of the E0 y* T- K0 + N$o. Error: steam pressure is good % k$, j, A3, u, W, Q, O, U0, h, boiler steam pressure selection, mainly depends on the needs of users. The vapor pressure of low pressure parts, favorable safety, energy consumption is low, but the quality of the steam enthalpy is poor, low humidity, even difficult to meet the needs of disinfection, sterilization, cultivation, heating and power generation. But the pressure is too high, the energy consumption is high, the corresponding line and bear the pressure of the valve pipe steam equipment, high maintenance requirements are also high, steam production and transportation in the process of heat dissipation, leakage loss is great. At the same time, high pressure steam carrying salt increased with the pressure increased, the salt makes water wall tube, pipe, boiler tube, heating surface fouling, overheating, blistering, jam or even increase the likelihood of pipe explosion. When the steam salinity enters the turbine, the flow area of the steam turbine is reduced, the internal efficiency is reduced, and the heat transfer is seriously affected - Y* Q (f P1 U7 o D$p+ D! Therefore, fireman must work in accordance with the provisions of the pressure operation, generally allows steam pressure fluctuations in the value of 0.05 ~ 0.15MPa. (L, J0, Z4, J, U3, Z6 [, Y5, S, F! Misunderstanding two: pot water level, the higher the security # Q%? 3 P+ T4 a: L6 S* D- F |# [some people think that the water level is high, the boiler is not