MW循环流化床二次风机采用双动调轴流式风机可研性研究.docVIP

300MW循环流化床二次风机采用双级动调轴流式风机可行性研究 摘要：300MW及以上大型循环流化床机组二次风机参数，非常接近燃煤600MW及以上大型机组的一次风机参数。本文提出能否选用一次风机普遍采用的双级动调轴流式风机作为二次风机。通过参数、失速安全、效率、技术结构、经济效益、初投资和维护等方面比较，得出300MW及以上循环流化床二次风机可选用双级动调轴流式风机的结论。 关键词：300MW循环流化床；二次风机；双级动调轴流式风机；离心式风机 中图分类号：TH432.1 文献标志码：A Feasibility Study of Useing Two-stage Dynamic Adjustable Axial Flow Fan for 300MW Circulating Fluidized Bed Secondary Air Fan Abstract: Considering the parameter of 300MW and over 300MW large-scale circulating fluidized bed secondary air fan is very close to the 600MW and over 600MW coal fire large-scale primary air fan. This paper propose that whether we can choose two-stage dynamic adjustable axial flow fan instead of the 300MW and over 300MW large-scale circulating fluidized bed secondary air fan. And the two-stage dynamic adjustable axial flow fan is in general used for the 600MW and over 600MW coal fire large-scale primary air fan.We can get this conclusion by comparing with parameters，stall safety，efficiency，technological structure，economic benefit，initial cost and maintenance. Key words: 300MW CFB；secondary air fan ； two-stage dynamic adjustable axial flow fan； centrifugal fan 0 引言 0 the introduction 　　300MW循环流化床已广泛应用于火力发电项目，据不完全统计，至今已运行的机组达42台之多，使我国大量煤矸石、煤泥等煤炭附属品得以充分利用。在这42台300MW循环流化床机组（以下简称42台机组）中使用的二次风机绝大部分是传统离心式风机或离心式风机加变频设备。在对42台机组二次风机参数进行查看过程中，发现其较接近600MW燃煤机组一次风机的参数，于是提出300MW循环流化床机组二次风机，能否选用已成熟使用于600MW燃煤机组一次风机类似的双级动调轴流式风机方案。 300 mw circulating fluidized bed has been widely used in thermal power project, according to incomplete statistics, the unit has been running for 42 units, make our country a large number of coal gangue, coal slime, such as accessories to make full use of. In the 42 units of 300 mw circulating fluidized bed unit (hereinafter referred to as units) 42 secondary fan for the most part is used in the traditional centrifugal fan and centrifugal fan with variable frequency device. At the second fan parameters of 42 units view in the process, found that the more close to 600 mw coal-fired unit onc