高压氧气管线清洗方案.docVIP

表格J-B－第 PAGE 6页 共 NUMPAGES 28页 联系人：韩玉峰 电 话 B) Chemical Cleaning Method Statement for HP OXYGEN SYSTEM AND HP N2 SYSTEM 高压氧气管线及高压氮气系统的化学清洗施工方案 Table of Contents 目 录 INTRODUCTION 概述 THE BASIC DATA FOR THE SCHEME 方案编制依据 EXPLANATION FOR CHEMICAL CLEANING OF HP PXYGEN SYSTEM 关于高压氧气系统化学清洗的说明 chemical cleaning scope AND PROCESS PROCEDURE 清洗系统的范围及清洗工艺流程 Duties 责任分工 Cleaning equipments provided by Blue Star 清洗设备 Cleaning solution flow cHART AND the chart OF FLOW direction 化学清洗工艺流程图及清洗流向示意图 THE PROCEDURE OF DISMANTLEMENT for CLEANING 清洗拆除程序 Cleaning procedure and Key points 清洗工序及控制要点 Cleaning quality standard 清洗质量标准 Treatment of waste WATER 废液处理 Method of Analysis and testing 分析化验方法Ⅰ. INTRODUCTION 概述： The important of meticulous degreasing and careful cleaning cannot be over-empHasized, since remnants of organic matter and minute solid particles in the presence of high pressure and/or high velocity can cause burning with the possibility of violent reaction. Great attention shall, therefore, be paid to the cleanliness of oxygen systems. Precleaned condition has not been maintained during construction .so chemical cleaning after construction is very important and need to be accomplished by special contractor. BULE STAR has strength and pay so great attention to the cleanliness of oxygen systems that separately doing chemical cleaning scheme for oxygen systems. 高压氧气系统清洗的重要性是显而易见的，这里不必过多强调，由于在高压氧气系统中，残留的有机物和小的固体杂质能导致燃烧引起剧烈的反应，应该对氧气系统的清洗予以重视，而且系统没有经过前期的予清洗步骤，因此系统安装后的化学清洗非常重要，需要专业的承包商来完成，我公司具有这样的实力，也对该系统予以高度重视，特别对该系统单独做了一个化学清洗方案。 Ⅱ.THE BASIC DATA OF THE SCHEME ESTABLISHMENT 方案编制依据 1. The scope and technical requirements of the chemical cleaning for the pipelines and equipment