利用废弃混凝土作为水泥原料试验研究.pdfVIP

学兔兔 2010年 第 1期 (总第 243期 ) 混 凝 土 原材料及辅助物料 Number 1 in 2010(Total No．243) Concrete MATERIAI AND ADMINICLE doi：10．3969／j．issn．1002—3550．2010．01．025 利用废弃混凝土作为水泥原料的试验研究 袁启涛’。万朝均。 (1．中建商品混凝土有限公司，湖北武汉430074；2．重庆大学材料科学与工程学院，重庆400045) 摘 要：从不同建筑物拆除现场随机选取以石灰石为骨料的废弃混凝土样品，分别破碎、分离，获得以石灰石为主的颗粒，作为钙质原料 煅烧水泥熟料，将该水泥熟料与水泥厂生产的熟料以及市售水泥进行了对比。研究结果表明：所烧成的熟料中4种主要矿物的XRD特征 峰明显；游离CaO低于国家规定标准；利用烧成的熟料配制的水泥28 d强度与市售P·O42．5级水泥强度相当。 关键词：废弃混凝土；钙质原料；水泥熟料；石灰石 中图分类号：TU528．041 文献标志码：A 文章编号： 1002—3550(2010)01—0075-03 Experimental study on using abandoned concrete as cement raw materials ~ Qi-tao ，WANChao-jun。 (1．ReadyMix CompanyofCSCEC，Wuhan 430074，China； 2．CollegeofMaterial Science andEngineeringofChongqingUniversity，Chongqing400045，China) Abstract： Abandoned concrete with limestone aggregate were selected from demolishing site．Each sample was crushed into particles which were then screened out the smaller part by sieve with given size and the residue was kept to use respectively．Most ofthe residue is the crushed limestone，it was used to replace the natural limestone as the calcareous raw material tO produce cement raw mea1．And it was compared with the cemem clinkers produced by Runjiang plant as well as some selected Portland cements on sale．The comparative analysis results ofX—ray diffractions show that the characteristicpeaksoffourprincipal compoundsisclearinthecementclinkersproducedbydemolishedconcrete．thef．Ca0ofthecementclinkermeet the requirement of China standards．Experimental results on mechanical properties show that