利用粉煤灰和聚丙烯纤维配制渠道衬砌混凝土试验研究.pdfVIP

学兔兔 2014年第 1期(总第 291期 ) 混 凝 土 实 用 技 术 Number 1 in 2014(Total No．291) Concrete PRACTICAL TECHNOL0GY 利用粉煤灰和聚丙烯纤维配制渠道 衬砌混凝土的试验研究 解国梁，张兆强，王海波 (黑龙江八一农垦大学工程学院，黑龙江 大庆 1633 19) 摘 要：研究了水胶比、粉煤灰掺量、聚丙烯纤维掺量对混凝土抗压强度、抗折强度和劈裂抗拉强度的影响。结果发现，即使粉 煤灰掺入量达到300 g／kg，混凝土的强度等级也在C30以上；纤维掺量对混凝土抗折强度和劈裂抗拉强度的影响规律基本一致， 纤维掺量越大混凝土抗折、抗拉强度越大。这表明，在渠道衬砌混凝土中掺入适当比例的粉煤灰和聚丙烯纤维是可行的，能满足 渠道衬砌对混凝土的强度要求。 关键词：力学性能；正交试验；粉煤灰掺量；纤维掺量；水胶比；渠道衬砌混凝土 中图分类号：TU528．041 文献标志码：A 文章编号： 1002—3550(2014)01—0143—04 Experimental study on properties of fly ash concrete containing polypropylene fibers for canal liner XIEGuoliang，ZHANGZhaoqiang，WANGHaibo (College ofEngineering Heilongjiang Sayi Agricultural University，Daqing 163319，China) Abstract： The effects ofwater—cement ratio，the amount offly-ash and fibers on compressive strength，flexural strength and split tensile strength of the concrete were studied．The results suggested that an addition of 300 kg fly—ash met the requirement of the compressive strength used in canal liner．Fiber content has large impact on flexural and splitting tensile strength next only to the water—binder ratio，and flexural and splitting tensile strength of concrete increase with the increase of the fiber content．This showed that the concrete produced with fly-ash and fibers could achieve ideal s~ength and could be used as canal liner through a reasonable selection of the fy-ash and polypropylene fibers contents． Keywords： mechanicalproperty；o~hogonaltest；contentofflyash；fibers content；water—binder rmio；concrete ofcanalliner 试图在不增加水泥用量的前提下，通过调整粉煤灰和聚丙 0 引言