旋转电极5kHz介质阻挡放电臭氧制备.PDF

第 42 卷 第 2 期：439-445 高电压技术 Vol.42, No.2: 439-445 2016 年 2 月 29 日 High Voltage Engineering February 29, 2016 DOI: 10.13336/j.1003-6520.hve.2016.02.014 旋转电极 5 kHz 介质阻挡放电臭氧制备 1 2 于大海 ，叶齐政 1. 266061 （ 国网山东省电力公司青岛供电公司，青岛 ； 2. 华中科技大学强电磁工程与新技术国家重点实验室，武汉430074 ） 摘 要：臭氧在食品杀菌消毒等方面有广阔的应用前景。为研究影响臭氧体积分数及产率的影响因素，采用旋转 电极介质阻挡放电制备臭氧，给出转速、流量和电压对臭氧体积分数、产量及产率的试验结果，并采用正交实验 对各影响因素显著性进行了分析。结果发现：在电压较低时，转速增加，臭氧体积分数和产率提高；流量增加， 臭氧体积分数降低，产率增加。这说明电极旋转使等离子体与空气充分混合在一定程度上可以提高臭氧产率。电 压增加使臭氧体积分数提高，但臭氧产率先增加后减小。正交实验结果发现，电压对臭氧体积分数有显著影响， 而流量对臭氧产量有显著影响。这对提高臭氧制备产率有指导作用。 关键词：臭氧；大气压空气；旋转电极；正交实验；介质阻挡放电；产率 Ozone Generation Using 5 kHz Dielectric Barrier Discharge with Rotating Electrode 1 2 YU Dahai , YE Qizheng (1. Qingdao Power Supply Company, State Grid Shandong Electric Power Company, Qingdao 266001, China; 2. State Key Laboratory of Advanced Electromagnetic Engineering and Technology, Huazhong University of Science and Technology, Wuhan 430074, China) Abstract ：Ozone has broad prospects in food sterilization and so on. To investigate the impacts of the yield and con- centration of ozone, the dielectric barrier discharge with rotating electrode was prepared to study the effects of the speed, gas flow and voltage on the ozone concentration, ozone yield and ozone production. Moreover, each significant factors were analyzed using orthogonal tests. The results show that, at a lower voltage, the ozone concentration increases when the speed increases; the ozone concentration decreases and the yie